|
ECU ABS 故障代码 40B01 故障部件 左前车轮感应器故障 ABS ABS ABS ABS ABS ABS ABS ABS ABS ABS ABS ABS 40B02 右前车轮感应器故障 故障 类别 01 轮速传感器与齿圈间的间 隙太大， 传感器输出电压 太低，但刚好超过触发水 平 轮胎与齿圈的比率：前桥 02 相差10%，后桥相差超过 19%，检查轮胎外径和齿 圈 检查有直流电压，可能是 03 短路或者蓄电池电压有阻 抗 04 检查出短路（接地） 05 检查出断路 传感器线IG和IGM之间短 06 路 07 速度超过10公里/小时 时，不断检测到失灵。 需 要车轮转动再检查 08 检查出持续16秒的滑动 检测到另一个感应器的IG 或IGM线 车轮转速信号临时丢失。 气隙过大，丢失速度信号 刹车挤压或者咔哒作响 测量到不可靠的感应器频 率 轮速传感器与齿圈间的间 隙太大， 传感器输出电压 太低，但刚好超过触发水 平 轮胎与齿圈的比率：前桥 相差10%，后桥相差超过 19%，检查轮胎外径和齿 圈 检查有直流电压，可能是 短路或者蓄电池电压有阻 抗 检查出短路（接地） 检查出断路 09 10 11 12 01 说明 ABS 02 ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D 03 04 05 传感器线IG和IGM之间短 06 路 07 速度超过10公里/小时 时，不断检测到失灵。 需 要些车轮转动 08 检查出持续16秒的滑动 检测到另一个感应器的IG 09 或IGM线 车轮转速信号临时丢失。 10 气隙过大，丢失速度信号 11 刹车挤压或者咔哒作响 ABS Wabco D ABS Wabco D 40B03 左后车轮感应器故障 ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D 测量到不可靠的感应器频 率 轮速传感器与齿圈间的间 隙太大， 传感器输出电压 太低，但刚好超过触发水 平 轮胎与齿圈的比率：前桥 相差10%，后桥相差超过 19%，检查轮胎外径和齿 圈 检查有直流电压，可能是 短路或者蓄电池电压有阻 抗 检查出短路（接地） 检查出断路 12 01 02 03 04 05 传感器线IG和IGM之间短 06 路 07 速度超过10公里/小时 时，不断检测到失灵。 需 要些车轮转动 08 检查出持续16秒的滑动 检测到另一个感应器的IG 09 或IGM线 车轮转速信号临时丢失。 10 气隙过大，丢失速度信号 11 刹车挤压或者咔哒作响 测量到不可靠的感应器频 率 轮速传感器与齿圈间的间 隙太大， 传感器输出电压 太低，但刚好超过触发水 平 轮胎与齿圈的比率：前桥 相差10%，后桥相差超过 19%，检查轮胎外径和齿 圈 检查有直流电压，可能是 短路或者蓄电池电压有阻 抗 检查出短路（接地） 检查出断路 12 01 40B04 右后车轮感应器故障 ABS Wabco D 02 ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D 03 04 05 传感器线IG和IGM之间短 06 路 07 速度超过10公里/小时 时，不断检测到失灵。 需 要些车轮转动 08 检查出持续16秒的滑动 检测到另一个感应器的IG 09 或IGM线 ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D 车轮转速信号临时丢失。 10 气隙过大，丢失速度信号 11 刹车挤压或者咔哒作响 测量到错误的感应器频率 12 40B07 左前调节器不工作 发现直流电压，短路 断路 感应器线IG和IGM之间发 现短路 发现直流电压，短路 断路 感应器线IG和IGM之间发 现短路 发现直流电压，短路 断路 感应器线IG和IGM之间发 现短路 发现直流电压，短路 断路 03 05 06 03 05 06 03 05 06 03 05 40B08 右前调节器不工作 40B09 左后调节器不工作 40B0A 右后调节器不工作 40B0D DBR.缓速器 感应器线IG和IGM之间发 06 现短路 发现DC电压，短路或者蓄 03 电池电压有阻抗 05 断路 感应器线IG和IGM之间发 现短路 发现短路（与接地端） 断路 06 04 05 40B0E ABS错误 40B0F ABS错误 速度超过10公里/小时时， 07 不断检测到失灵。 需要些 车轮转速 检查到直流电，短路或者 03 与电源连接时有阻抗 04 与接地点短路 断路 05 感应器线IG和IGM之间发 06 现短路 速度超过10公里/小时时， 07 不断检测到失灵。 需要些 车轮转速 ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D 40B10 ABS错误 检查到直流电，短路或者 03 与电源连接时有阻抗 05 断路 检查到直流电，短路或者 03 与电源连接时有阻抗 05 断路 感应器线IG和IGM之间发 06 现短路 检查到直流电，短路或者 03 与电源连接时有阻抗 05 发现开路 IG和IGM感应线之间发现 06 短路 08 发现开路 里程表车速和ABS车速两 者不匹配 SAE J1939无法数据交互 高SAE J1939开路或与正 极或是地线短路；低SAE J1939或低/高被误用 SAE J1939 通讯无效 SAE J1939断路 缓速器发送信息错误。 激活时检测到暂停监控错 误 缓速器发送信息错误。 激活时检测到暂停监控错 误 变速器发送数据错误 激活时检测到暂停监控错 误 发动机控制发送扭矩信息 错误 检测到暂停监控错误 缓速器发送信息错误。 激活时检测到暂停监控错 误 内部错误 供电电压过高超过5秒 05 02 05 40B12 ABS错误 40B13 ABS错误 40B16 40B17 40BE7 ABS错误 ABS错误 ABS错误. SAE J1939 ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D ABS Wabco D 06 07 08 09 09 10 12 03 40BFB 40BFD ABS错误. 超电压 ABS错误 40BFE ABS错误 轮胎参数超过公差. 没有 02 ABS，ASR，EBL，SM 参数校验或者类似的调整 12 错误 05 没有调节器连接 车辆的一个桥比其它桥速 08 度快 40BFE ABS错误 ABS Wabco D ABS Wabco D BC IBC2 BC IBC2 通过调节器进行的控制过 09 长。 延迟一段时间后功能 正常。 12 内部错误 22101 22102 EEPROM 校验和错误 ECU过热 车身电脑内存出错 输出驱动的连接处温度高 于最大的温度值（150 度） 要求的电压低于或高过初 始值。 12 12 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 22103 电源电路1 22104 电源电路2 要求的电压低于或高过初 始值。 22105 电源电路3 要求的电压低于或高过初 始值。 22106 电源电路4 要求的电压低于或高过初 始值。 22107 电源电路5 要求的电压低于或高过初 始值。 22108 BC IBC2 22109 BC IBC2 BC IBC2 BC IBC2 2210A 2210B 2210C BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 2210D 2210E 2210F 22110 22111 BC IBC2 22112 要求的负载电流低于额定 值（三个灯泡至少有一个 开路） 拖车右转向灯 开/关诊断。 只有停车时 才可以进行测试。 只有开 路的时候才能检测到错误 。 右转向灯或拖车右转向灯 检查到有短路、接地、超 负荷、过热故障。 左转向灯 电压过低 拖车左转向灯 开/关诊断。 只有停车时 才可以进行测试。 只有开 路的时候才能检测到错误 。 左转向灯或拖车左转向灯 检查到有短路、接地、超 负荷、过热故障。 左停车& 右前信号灯 要求的负载电流低于临界 值（至少一个断路） 右后停车灯 要求的负载电流低于临界 值（至少一个断路） 牌照灯 要求的负载电流低于临界 值（至少一个断路） 左停车&右前信号灯 或者 电压过低 右后停车灯 或者 牌照灯 或者挂车灯 后停车&左前信号灯 要求的负载电流低于临界 值（三个中至少一个断 路） 右转向灯 00 01 03 04 00 01 03 04 00 01 03 04 00 01 03 04 00 01 03 04 05 05 06 05 05 06 05 05 05 06 05 BC IBC2 22113 左后停车灯 后信号灯 BC IBC2 22114 BC IBC2 22115 BC IBC2 22116 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 22117 22118 22119 2211A 2211B BC IBC2 BC IBC2 2211C 2211D BC IBC2 BC IBC2 2211E 2211F BC IBC2 BC IBC2 BC IBC2 BC IBC2 s右停车&左前信号灯 或 者左后停车灯 或者后信号 灯或者 停车&拖车信号&左 侧信号灯 左后和右后雾灯 要求的负载电流低于临界 值（两个中至少一个断 路） 左&右后雾灯或者拖车左& 检查到有短路、接地、超 负荷、过热故障。 右后雾灯 左后停车灯 要求的负载电流低于临界 值（唯一的负载开路） 右后停车灯 要求的负载电流低于临界 值（唯一的负载开路） 左停车灯或者右停车灯或 检查到有短路、接地、超 负荷、过热故障。 者拖车左右停车灯 转向灯开关 左转和右转开关同时被通 电。 CAN't线左转向灯和 右转向灯状态参数是“开 ”但是CAN't线紧急灯状态 是“关” 风挡雨刮器 供电电路6故障、电机卡滞 、短路、接地 发动机制动预选模式开关 发动机制动模式下加速器 怠速和制动踏板开关同时 被激活 差速锁开关 差速锁开关同时打开 前制动气压感应器 要求电压低于或高于临界 值 只有在感应器的供电电压 没有错误时才会发现错误 感应器的输出电压；Vc： 感应器的供电电压；Bar： 大气压力 要求的负载电流低于临界 05 值（三个中至少一个断 路） 要求的负载电流低于临界 05 值（三个中至少一个断 路） 06 电压过低， 05 06 05 05 06 02 02 02 02 00 22120 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 BC IBC2 2212B 2212B 2212B 2212B 2212C 2212D 22130 01 03 04 后制动气压传感器 要求电压低于或高于临界 00 值 只有在感应器的供电电压 没有错误时才会发现错误 感应器的输出电压；Vc： 感应器的供电电压；Bar： 01 03 大气压力 04 00 (Vc) 制动气压传感器电源 电压过低或过高 01 03 04 没有CAN信号，只有重新 02 加载CAN时才能读本信号 31 03 电压过高或短路 CAN整车数据总线CAN ECU未编程 发动机起动机 BC IBC2 BC IBC2 BC IBC2 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 22130 22131 21701 21704 21705 21706 Engine Starter 电压过高或短路 驾驶室内白顶灯（只在E03 电压过高或短路 的针脚） 电压过高或短路 EEPROM校验总值 IC内存错误后检查出校验 总值 步进电机 仪表的电机出错 燃油液面传感器 电压过高或过低 机油液面传感器 电压过高或过低 04 03 04 12 12 03 00 01 03 04 15 16 17 18 19 20 21707 环境温度感应器 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 IC SPR1 E4 2170C 2170D 2170E 2170F 21710 21711 21712 21713 车辆数据总线 CAN 车辆数据总线 -ECU#1 CAN 车辆数据总线 -ECU#2 CAN 车辆数据总线 -ECU#3 CAN 车辆数据总线 -ECU#4 CAN 车辆数据总线 ECU#5CAN 车辆数据总线 -ECU#6 CAN 车辆数据总线 -ECU#7 CAN 车辆数据总线 ECU#8CAN 车辆数据总线 -ECU#9 CAN 加速踏板1故障 IC SPR1 E4 IC SPR1 E4 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 21714 21715 10012 检测到环境温度界面错误 。 反跳时间（错误出现和 不出现状态）是4秒。输入 电压用于评估范围内的检 查 无CAN信号 IBC 接收不到从ECU#1 车身电脑来的CAN信号 接收不到从ECU#2-电控 喷油装置来的CAN信号 接收不到从ECU#3-TCO 来的CAN信号 接收不到从ECU#4 - ETC 来的CAN信号 接收不到从 ECU#5 EBC来的CAN信号 接收不到从 ECU#6 ECAS来的CAN信号 接收不到从ECU#7 -动力 传动系统缓速器来的CAN 信号 接收不到从ECU#8 -电控 后视镜来的CAN信号 接收不到从ECU#8 -膨胀 模块来的CAN信号 APP1 03 04 02 02 02 02 02 02 02 02 02 02 03 04 02 10012 加速踏板1故障 APP1 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 12 10013 10016 10016 10017 10017 10019 20011 20011 20011 20011 20015 30015 10025 加速踏板/制动可靠性 主离合器信号错误 Main clutch signal 制动信号错误 Brake signal failure 终端15故障 车速传感器错误 AccPedPlausBrk ConvCD ConvCD BrkCD BrkCD T15CD VSSCD2 12 02 12 02 12 02 03 04 02 12 12 12 MFLv_Rvrs Vehicle Speed Sensor VSSCD2 failure Vehicle Speed Sensor VSSCD2 failure Vehicle Speed Sensor VSSCD2 failure 巡航控制按钮不可逆错误 MFLv_Irvrs 巡航控制按钮可逆错误 主继电器2错误（栅格加热 MRlyCD 器1，风扇1，VGT，Lambda 加热器，EGR件，曲轴箱通 风阀） 蓄电池电压故障 Battery voltage fault 发动机制动解压阀 En 主继电器1（高压泵）与 蓄电池短接 主继电器3（A/C 压缩/燃 油过滤器加热） BattCD BattCD CRERCD CRERCD MnRly1_SCB MRlyCDMnRly3 03 04 03 04 03 04 03 03 04 10026 10026 10027 10027 10028 10029 10029 1002A 1002A 1002B 1002B 1002B 主继电器4(排气阀发动机 EVCD 制动拍打) Main relay 4 (Exhaust EVCD valve eng.brake flap) 空气加热器１的驱动器故 ArHt1 障 03 04 03 04 02 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 1002E 20025 20028 空气加热器始终打开 AirHtStickOnIv 03 03 04 10031 10031 10031 10031 10032 10033 10033 10033 10034 10034 10034 10034 10035 10035 10036 10036 10037 10037 主继电器故障（启动后阻 MRlyCDAftRun 断） MnRly1_SCG 主继电器SCGND （Lambda加热气／栅格加 热器／电池开关） CTSCD 冷却液温度传感器 03 04 02 12 冷却液温度传感器动态测 Clg_DynTst 试 增压气体温度传感器错误 IATSCD 12 03 04 02 增压压力传感器 BPSCD 03 04 02 12 燃油温度传感器错误 FTSCD 03 04 03 04 03 04 Fuel Temperature Sensor FTSCD failure RailCD 轨压传感器CP3 Rail pressure sensor CP3 RailCD 共轨压力限制阀错误 PRVMon 10037 10038 10038 10038 10038 1003A 机油温度传感器 OTSCD 机油压力传感器错误 OPSCD 02 03 04 02 12 03 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 1003A 1003A 1003A 20032 Oil Temp. Sensor Oil Temp. Sensor OTSCD OTSCD 04 02 12 冷却液温度传感器完全测 ClgAbsTst 试 共轨压力传感器 RailCDOfsTst 12 20036 20036 20038 2003A 10041 10041 10042 10043 10043 10044 1004A 2004A 1004D 1005B 2009D 03 04 机油压力过低 机油温度高过正常值 曲轴传感器错误 OPSCD1 OTSCD1 EngMCrS1 12 12 02 04 03 02 04 03 02 02 03 03 04 Crankshaft sensor failure EngMCrS2 只有凸轮轴传感器运行 凸轮轴速度传感器错误 Camshaft sensor failure EngMBackUp EngMCaS1 EngMCaS2 凸轮轴和曲轴之间信号抵 EngMOfsCaSCrS 消 ECBtCDStart 发动机副起动按钮 发动机副熄火按钮 发动机超速保护 高压测试（轨压监测无 效） Torque Limitation due to Negative Torque Coordinator 负扭矩等效器 导致的扭矩限制 由于涡轮增压器保护导致 扭矩极限 由于发动机保护（由于过 度扭矩，发动机超速和过 热）导致的扭矩极限 由于喷油系统错误导致燃 油量变化，导致的扭矩极 限 轨道压力正偏差过大和燃 油流量设定值过高 最小测定时共轨压力负偏 差过高 在控制状态下共轨压力低 于最小限制 ECBtCDStop EngPrtOvrSpd HpTst NTCTrqLim ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 3009E 4009E BstPrtTrqLim EngPrtTrqLim 04 04 6009E QLimTrqLim 04 10052 10053 10054 RailMeUn1 RailMeUn2 RailMeUn3 03 03 03 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 10055 10056 10057 10058 10059 10059 20059 30059 10061 10061 10061 10061 10062 10062 10062 10062 10063 10063 10063 10063 10064 10064 10064 10064 10065 10065 10065 轨压在控制模式下高于最 RailMeUn4 大限值 轨压下降斜率高于预测值 RailMeUn6 共轨监控单元设定的值在 RailMeUn7 超出限度时不可靠 共轨监控单元的燃油流量 RailMeUn10 设定值过低 共轨油压计量单元故障 MeUnCDNoLoad Common Rail Metering Unit Power Stage failure 共轨油压计量单元与电源 短接 共轨油压计量单元与地线 短接 汽缸1喷油器错误 MeUnCDNoLoad MeUnCDSCBat MeUnCDSCGnd InjVlvCyl1A 03 03 03 03 02 12 03 04 03 04 02 12 03 04 02 12 03 04 02 12 03 04 02 12 03 04 02 Injector Cylinder 1 failure InjVlvCyl1A Injector Cylinder 1 failure InjVlvCyl1A Injector Cylinder 1 failure InjVlvCyl1A 汽缸2喷油嘴错误 InjVlvCyl2A Injector Cylinder 2 failure InjVlvCyl2A Injector Cylinder 2 failure InjVlvCyl2A Injector Cylinder 2 failure InjVlvCyl2A 汽缸3喷油嘴错误 InjVlvCyl3A Injector Cylinder 3 failure InjVlvCyl3A Injector Cylinder 3 failure InjVlvCyl3A Injector Cylinder 3 failure InjVlvCyl3A 汽缸4喷油嘴错误 InjVlvCyl4A Injector Cylinder 4 failure InjVlvCyl4A Injector Cylinder 4 failure InjVlvCyl4A Injector Cylinder 4 failure InjVlvCyl4A 汽缸5喷油嘴错误 InjVlvCyl5A Injector Cylinder 5 failure InjVlvCyl5A Injector Cylinder 5 failure InjVlvCyl5A ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 10065 10066 10066 10066 10066 10067 10067 10067 10067 10068 10068 10068 10068 10069 10069 10069 10069 1006A 1006A 1006A 1006A 1006B 1006B 1006B 1006B 1006C 1006C Injector Cylinder 5 failure InjVlvCyl5A 汽缸6喷油嘴错误 InjVlvCyl6A 12 03 04 02 12 03 04 02 12 03 04 02 12 Injector Cylinder 6 failure InjVlvCyl6A Injector Cylinder 6 failure InjVlvCyl6A Injector Cylinder 6 failure InjVlvCyl6A 汽缸1喷油嘴警告 Injector Cylinder 1 warning Injector Cylinder 1 warning Injector Cylinder 1 warning 汽缸2喷油嘴警告 InjVlvCyl1B InjVlvCyl1B InjVlvCyl1B InjVlvCyl1B InjVlvCyl2B 汽缸3喷油嘴警告 Injector Cylinder 3 warning Injector Cylinder 3 warning Injector Cylinder 3 warning 汽缸4喷油嘴警告 Injector Cylinder 4 warning Injector Cylinder 4 warning Injector Cylinder 4 warning 汽缸5喷油嘴警告 Injector Cylinder 5 warning Injector Cylinder 5 warning Injector Cylinder 5 warning 汽缸6喷油嘴警告 Injector Cylinder 6 warning InjVlvCyl3B InjVlvCyl3B InjVlvCyl3B InjVlvCyl3B InjVlvCyl4B InjVlvCyl4B InjVlvCyl4B InjVlvCyl4B InjVlvCyl5B InjVlvCyl5B InjVlvCyl5B InjVlvCyl5B InjVlvCyl6B InjVlvCyl6B 03 04 02 12 03 04 02 12 03 04 02 12 03 04 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 1006C 1006C 1006E 10071 10071 Injector Cylinder 6 warning Injector Cylinder 6 warning 未达到最低喷射量 喷油器密闭腔1故障 Bank 1 specific errors Short circuit / not classifyable Bank 1 specific errors Short circuit / not classifyable Bank 1 specific errors Short circuit / not classifyable 喷油器密闭腔2故障 InjVlvCyl6B InjVlvCyl6B InjVlvNumMinInj InjVlvBnk1A InjVlvBnk1A 02 12 03 03 04 10071 InjVlvBnk1A 02 10071 InjVlvBnk1A 12 10073 10073 10073 10073 1007C 1007C 1007C 1007C 2007C 2007C 2007C 2007C 1009E 100B1 100B2 100B3 100B4 100B7 200B4 InjVlvBnk2A 03 04 02 12 ECU喷油硬件：CY33X模块 特殊故障(1) Chip-specific errors->stop engine Chip-specific errors->stop engine Chip-specific errors->stop engine ECU喷油硬件：CY33X模 块特殊故障(2) Chip-specific errors->stop engine Chip-specific errors->stop engine Chip-specific errors->stop engine 烟雾限制导致的扭矩减小 CAN A与CANA总线传输 中断 CAN B与CANB总线传输 中断 CAN C与CANC总线传输 中断 BC-EDC信号超时 CAN传输信号超时 BC-EDC2信号超时 InjVlvChipA InjVlvChipA InjVlvChipA InjVlvChipA InjVlvChipB InjVlvChipB InjVlvChipB InjVlvChipB SmkTrqLim NetMngCANAOff NetMngCANBOff NetMngCANCOff FrmMngTOBC2EDC1Iv FrmMngTxTO FrmMngTOBC2EDC2Iv 03 04 02 12 03 04 02 12 04 03 03 03 02 02 02 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 100C3 100D1 100D2 100D2 100D2 100D3 100D4 100D5 100D5 100D5 100D6 100D7 100D7 100D8 100D9 100D9 100D9 100D9 200D3 300D3 100E1 100E1 TCO--CAN信息TCO1超时 ECU硬件 SPI通信故障 ECU硬件：EEPROM故障 FrmMngTOTCO1 HWEMonCom HWEMonEEPROM 02 03 04 02 12 ECU 锁定解除-ECU锁定 HWEMonRcyLocked 12 12 04 02 12 ECU硬件：微控制器看门 Montr 狗故障 ECU硬件：初始化时中断 SOPTst ECU硬件：TPU监控 ECU软件：变量数据设定 故障 ECU Software: Variant Dataset failure ECU硬件：控制看门狗故 障 ADC监控故障 ADC Monitoring failure ADC Monitoring failure ADC Monitoring failure ECU解除锁定—被抑制 ECU锁定解除-可见的 ECU硬件：接地短路或断 电 ECU Hardware: High Side Power Stage Short to Ground or Battery 防盗器故障（没有燃油释 放） Overrun Monitoring failure超限监控故障 发动机超速 ECU 硬件：传感器 12V 供应电压故障 TPUMon VarMngCodDs VarMngCodDs WdCom ADCMon ADCMon ADCMon ADCMon 12 02 12 12 03 04 02 12 HWEMonRcySuppressed 12 HWEMonRcyVisible StrtCDHS StrtCDHS 12 03 04 100E2 100E3 100E4 100E5 ImmCtl OvRMon OvRMonSigA SSpMon12V 04 03 03 03 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 ECM EDCUC31 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 985 985 520192 520192 520192 520192 172 172 132 100E5 100E6 100E6 100E7 100E7 100E8 100E8 100E9 100EA 100EB 100EB 100EB 100EB ECU Hardware: Sensor 12V Supply Voltage failure ECU 硬件：传感器供应 电压1故障 ECU Hardware: Sensor Supply Voltage 1 failure ECU 硬件：传感器供应电 压2故障 ECU Hardware: Sensor Supply Voltage 2 failure ECU 硬件：传感器供应电 压3故障 ECU Hardware: Sensor Supply Voltage 3 failure ECU内部电压供应过高 ECU内部电压供应过低 气压传感器 Atmospheric Pressure Sensor Atmospheric Pressure Sensor Atmospheric Pressure Sensor ECU硬件：接地短路或与 电源短接 ECU Hardware: Low Side Power Stage Short to Ground or Battery ECU Hardware: Low Side Power Stage Short to Ground or Battery Dfp_ACCDSwtin 空压机开关故障 Dfp_ACCDSwtin 空压机开关故障 Dfp_ADCMon 模数转换器故障 Dfp_ADCMon 模数转换器故障 Dfp_ADCMon 模数转换器故障 Dfp_ADCMon 模数转换器故障 Dfp_AFSCD_AirTemp HFM传感器故障 Dfp_AFSCD_AirTemp HFM传感器故障 Dfp_AFSCD_PlOffsDrft HFM传感器漂移故障 SSpMon12V 04 SSpMon1 SSpMon1 SSpMon2 SSpMon2 SSpMon3 SSpMon3 HWEMonUMaxSupply HWEMonUMinSupply APSCD APSCD APSCD APSCD 03 04 03 04 03 04 03 04 03 04 02 12 200E1 200E1 StrtCDLS StrtCDLS 03 04 200E1 StrtCDLS 02 003D9 003D9 7F000 7F000 7F000 7F000 000AC 000AC 00084 Fault path of air condition power stage Fault path of air condition power stage Error status of ADC monitoring Error status of ADC monitoring Error status of ADC monitoring Error status of ADC monitoring Intake Air Temperature sensor Intake Air Temperature sensor error path for plausibility check of offset drift of airmass 12 02 03 04 11 02 03 04 03 Weichai 132 00084 Dfp_AFSCD_PlOffsDrft HFM传感器漂移故障 Dfp_AFSCD_PlSetyDrft 空气流量比故障 Dfp_AFSCD_PlSetyDrft 空气流量比故障 Dfp_AFSCD_SRCAirm 空气流量故障 Dfp_AFSCD_SRCAirm 空气流量故障 Dfp_APP1 油门踏板1故障 Dfp_APP1 油门踏板1故障 Dfp_APP1 油门踏板1故障 Dfp_APP2 油门踏板2故障 Dfp_APP2 油门踏板2故障 Dfp_APP2 油门踏板2故障 Dfp_APSCD 大气压力传感器故障 Dfp_APSCD 大气压力传感器故障 Dfp_APSCD 大气压力传感器故障 Dfp_APSCD 大气压力传感器故障 Dfp_ASLLCD 车速限制指示灯故障 Dfp_ASLLCD 车速限制指示灯故障 Dfp_ASLLCD 车速限制指示灯故障 Dfp_ASLLCD 车速限制指示灯故障 Dfp_AccPedPlausBrk Dfp_AirCtlGvnrDvtMax Dfp_AirCtlGvnrDvtMin Dfp_AirHtStickOn Weichai 520193 7F001 Weichai 520193 7F001 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 132 132 91 91 91 29 29 29 108 00084 00084 0005B 0005B 0005B 0001D 0001D 0001D 0006C Weichai Weichai Weichai Weichai 108 108 108 520194 0006C 0006C 0006C 7F002 Weichai 520194 7F002 Weichai 520194 7F002 Weichai 520194 7F002 Weichai Weichai Weichai Weichai 91 520195 520196 676 0005B 7F003 7F004 002A4 error path for plausibility check of offset drift of airmass fault path for plausibility check of sensitivity drift of airmass fault path for plausibility check of sensitivity drift of airmass error path for signal range check of airmass error path for signal range check of airmass fault path of Acclerator Pedal 1 fault path of Acclerator Pedal 1 fault path of Acclerator Pedal 1 fault path of Accelerator Pedal 2 fault path of Accelerator Pedal 2 fault path of Accelerator Pedal 2 error path of atmospheric pressure sensor 气压感应 器故障 error path of atmospheric pressure sensor error path of atmospheric pressure sensor error path of atmospheric pressure sensor Error path for the Adjustable Speed Limit lamp Error path for the Adjustable Speed Limit lamp Error path for the Adjustable Speed Limit lamp Error path for the Adjustable Speed Limit lamp Error path for AccPed and Brake Plausibility AirCtl permanent positive governor deviation AirCtl permanent negative governor deviation Grid heaters always switched on 04 03 04 03 04 03 04 02 03 04 02 03 04 12 02 03 04 05 02 07 15 17 07 Weichai Weichai Weichai Weichai Weichai Weichai Weichai 729 729 730 730 729 729 1192 002D9 002D9 002DA 002DA 002D9 002D9 004A8 Dfp_AirHt_Test1 进气加热器电压故障1 Dfp_AirHt_Test1 进气加热器电压故障1 Dfp_AirHt_Test2 进气加热器故障电压2 Dfp_AirHt_Test2 进气加热器故障电压2 Dfp_ArHt1 进气加热器故障 Dfp_ArHt1 进气加热器故障 Dfp_BPACD_Max Weichai 1192 004A8 Dfp_BPACD_Min Dfp_BPACD_SigNpl 增压器信号故障 Dfp_BPACD_SigNpl 增压器信号故障 Dfp_BPSCD 进气压力传感器故障 Dfp_BPSCD 进气压力传感器故障 Dfp_BPSCD 进气压力传感器故障 Dfp_BPSCD 进气压力传感器故障 Dfp_BattCD 电池电压故障 Dfp_BattCD 电池电压故障 Dfp_BrkCD 刹车信号故障 Dfp_BrkCD 刹车信号故障 Dfp_CABCD 中冷器旁通阀故障 Dfp_CABCD 中冷器旁通阀故障 Dfp_CABCD 中冷器旁通阀故障 Dfp_CLSCD 冷却水水位传感器故障 Dfp_CLSCD 冷却水水位传感器故障 Dfp_CLSCD 冷却水水位传感器故障 Weichai 1192 004A8 Weichai 1192 004A8 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 102 102 102 102 168 168 597 597 520197 00066 00066 00066 00066 000A8 000A8 00255 00255 7F005 fault path1 of air heater testswitch on fault path1 of air heater testswitch on fault path2 of air heater testswitch off fault path2 of air heater testswitch off error path of power stage air heater 1 actuator error path of power stage air heater 1 actuator fault path for short circuit to battery for BPA power stage fault path for short circuit to ground for BPA power stage fault path for no load and excess temparature for BPA power stage fault path for no load and excess temparature for BPA power stage Error path for boost pressure sensor Error path for boost pressure sensor Error path for boost pressure sensor Error path for boost pressure sensor battery voltage fault 电池 电压故障 battery voltage fault 03 04 03 04 03 04 03 04 12 02 03 04 12 02 03 04 Error path for brake signal 12 刹车信号故障 Error path for brake signal 02 刹车信号故障 03 error path of Intercooler Bypass Valve Powerstage error path of Intercooler Bypass Valve Powerstage 04 Weichai 520197 7F005 Weichai 520197 7F005 error path of Intercooler 12 Bypass Valve Powerstage error path for coolant level sensor error path for coolant level sensor error path for coolant level sensor 03 04 12 Weichai Weichai Weichai 111 111 111 0006F 0006F 0006F Weichai Weichai Weichai Weichai Weichai Weichai 111 1072 1072 1072 1072 1081 0006F 00430 00430 00430 00430 00439 Dfp_CLSCD 冷却水水位传感器故障 Dfp_CRERCD_Actr CRERCD故障 Dfp_CRERCD_Actr CRERCD故障 Dfp_CRERCD_Actr CRERCD故障 Dfp_CRERCD_Actr CRERCD故障 Dfp_CSLpCD 冷启动指示灯故障 Dfp_CSLpCD 冷启动指示灯故障 Dfp_CSLpCD 冷启动指示灯故障 Dfp_CSLpCD 冷启动指示灯故障 Dfp_CTSCD 冷却水温度传感器电压信 号故障 Dfp_CTSCD 冷却水温度传感器电压信 号故障 Dfp_CTSCD 冷却水温度传感器电压信 号故障 Dfp_CTSCD 冷却水温度传感器电压信 号故障 Dfp_ClgAbsTst Dfp_Clg_DynTst Dfp_CmbChbMisfire1 Dfp_CmbChbMisfire2 Dfp_CmbChbMisfire3 Dfp_CmbChbMisfire4 Dfp_CmbChbMisfire5 Dfp_CmbChbMisfire6 Dfp_CmbChbMisfireMul Dfp_CoVMDCSh Dfp_ComprTst Weichai Weichai Weichai Weichai 1081 1081 1081 110 00439 00439 00439 0006E error path for coolant level sensor Fault path of CRERCD condition power stage Fault path of CRERCD condition power stage Fault path of CRERCD condition power stage Fault path of CRERCD condition power stage Error path for the cold start lamp 冷启动灯路径 错误 Error path for the cold start lamp Error path for the cold start lamp Error path for the cold start lamp error path of coolant temperature sensor error path of coolant temperature sensor error path of coolant temperature sensor error path of coolant temperature sensor Coolant temperature sensor absolute test Coolant temperature sensor dynamic test error path for Misfire cylinder 1 error path for Misfire cylinder 2 error path for Misfire cylinder 3 error path for Misfire cylinder 4 error path for Misfire cylinder 5 error path for Misfire cylinder 6 error path for misfire in multiple cylinders physical plausibility DCS 02 03 04 255 255 03 04 12 02 03 Weichai 110 0006E 04 Weichai 110 0006E 12 02 Weichai 110 0006E Weichai Weichai 520198 520198 7F006 7F006 02 02 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 1323 1324 1325 1326 1327 1328 1322 520199 520200 0052B 0052C 0052D 0052E 0052F 00530 0052A 7F007 7F008 03 03 03 03 03 03 03 02 faultpath for compression 20 test Weichai 598 00256 Dfp_ConvCD 离合器状态信号错误 Dfp_ConvCD 离合器状态信号错误 Dfp_EATSCD 环境温度传感器故障 Dfp_EATSCD 环境温度传感器故障 Dfp_EATSCD 环境温度传感器故障 Dfp_EATSCDBET 环境温度传感器BET电压 故障 Dfp_EATSCDBET 环境温度传感器BET电压 故障 Dfp_EATSCDClgZn 环境温度传感器CLgZn电 压故障 Dfp_EATSCDClgZn 环境温度传感器CLgZn电 压故障 Dfp_EATSCDInAir 环境温度传感器InAir电压 故障 Dfp_EATSCDInAir 环境温度传感器InAir电压 故障 Dfp_EBSwPreSelPlaus Dfp_ECBCD EGR旁通阀故障 Dfp_ECBCD EGR旁通阀故障 Dfp_ECBCD EGR旁通阀故障 Dfp_ECBtCD Dfp_EGPpCDP3 排气管压力传感器故障 Dfp_EGPpCDP3 排气管压力传感器故障 Dfp_EGPpCDP3 排气管压力传感器故障 Weichai 598 00256 Weichai Weichai Weichai Weichai 171 171 171 520201 000AB 000AB 000AB 7F009 diagnostic fault path signals errors of main clutch signal diagnostic fault path signals errors of main clutch signal error path of environment air temperature sensor error path of environment air temperature sensor error path of environment air temperature sensor error path of BET temperature sensor error path of BET temperature sensor error path of ClgZn temperature sensor error path of ClgZn temperature sensor error path of Inside air temperature sensor 内部 空气温度感应器路径错误 error path of Inside air temperature sensor 内部 空气温度感应器路径错误 fault path for Engine Brake Pre-Selection switch status error path of power stage for EGR Bypass valve actuator error path of power stage for EGR Bypass valve actuator error path of power stage for EGR Bypass valve actuator fault path 1 for Engine Compartment Start Button Error path for Exhaust Gas Pipe Pressure Sensor Error path for Exhaust Gas Pipe Pressure Sensor Error path for Exhaust Gas Pipe Pressure Sensor 12 02 03 04 12 03 Weichai 520201 7F009 04 Weichai 520202 7F00A 03 Weichai 520202 7F00A 04 Weichai 520203 7F00B 03 Weichai 520203 7F00B 04 Weichai 520204 7F00C 02 Weichai 520205 7F00D 03 Weichai 520205 7F00D 04 Weichai 520205 7F00D 12 08 Weichai 1041 00411 Weichai 520206 7F00E 03 Weichai 520206 7F00E 04 Weichai 520206 7F00E 02 Weichai 2791 00AE7 Weichai 2791 00AE7 Weichai 2791 00AE7 Weichai 2791 00AE7 Weichai 190 000BE Weichai Weichai Weichai Weichai Weichai 636 636 190 190 190 0027C 0027C 000BE 000BE 000BE Weichai Weichai 533 1074 00215 00432 Weichai 1074 00432 Weichai 1074 00432 Weichai 1074 00432 Weichai 520236 7F02C Weichai Weichai Weichai 174 174 1071 000AE 000AE 0042F fault path for short circuit to battery for EGR power stage fault path for short circuit Dfp_EGRCD_Min to ground for EGR power stage fault path for no load and Dfp_EGRCD_SigNpl excess temparature for EGR power stage fault path for no load and Dfp_EGRCD_SigNpl excess temparature for EGR power stage if running with cam-shaft Dfp_EngMBackUp only is active the fault path is set Dfp_EngMCaS1 error path of camshaft failure 凸轮轴信号故障 Dfp_EngMCaS1 error path of camshaft failure 凸轮轴信号故障 Dfp_EngMCrS1 error path of crankshaft failure 曲轴信号故障 Dfp_EngMCrS1 error path of crankshaft failure 曲轴信号故障 error path of offset Dfp_EngMOfsCaSCrS between camshaft and crankshaft Fault path of engine Dfp_EngPrtOvrSpd Protection error path for Short circuit Dfp_ExFlCD_Max to Batt of power stage for Exhaust Flap actuator error path Short circuit to Dfp_ExFlCD_Min Ground of power stage for Exhaust Flap actuator error path for Open circuit Dfp_ExFlCD_SigNpl and excess temeprature 排气制动蝶阀故障 of Exhaust Flap actuator error path for Open circuit Dfp_ExFlCD_SigNpl and excess temeprature 排气制动蝶阀故障 of Exhaust Flap actuator fault Dfp_FMTC_NonMonoton FMTC_trq2qBas_MAP Map containes non strictly monotonus q curves Dfp_FTSCD FaultPath for Fuel Temperature sensor 燃油温度传感器故障 Dfp_FTSCD FaultPath for Fuel Temperature sensor 燃油温度传感器故障 Dfp_EGRCD_Max Dfp_FanCD error path of power stage 风扇执行器PWM信号故障 fan actuator Dfp_FanCD error path of power stage 风扇执行器PWM信号故障 fan actuator 03 04 05 02 12 12 11 12 11 07 15 03 04 12 02 13 03 04 03 Weichai 1071 0042F 04 Weichai 1071 0042F Dfp_FanCD error path of power stage 12 风扇执行器PWM信号故障 fan actuator Dfp_FanCD error path of power stage 风扇执行器PWM信号故障 fan actuator Dfp_FanCD2 风扇执行器数字信号故障 Dfp_FanCD2 风扇执行器数字信号故障 Dfp_FanCDEval 冷却风扇速度故障 Dfp_FanCDEval 冷却风扇速度故障 Dfp_FlFCD_FltFoulMax Dfp_FlFCD_FltFoulMin Dfp_FlFCD_FltFoulNpl Dfp_FlFCD_Htg 燃油滤清器加热器故障 Dfp_FlFCD_Htg 燃油滤清器加热器故障 Dfp_FlFCD_WtLvlMax Dfp_FlFCD_WtLvlMin Dfp_FlSys_FltFoul Dfp_FlSys_WtDet Dfp_FrmMngEngGsFlRtH tr Dfp_FrmMngEngGsFlRtH tr Dfp_FrmMngEngGsFlRtH tr Dfp_FrmMngEngGsFlRtH tr Dfp_FrmMngRxEngTmp2 Sens Dfp_FrmMngRxEngTmp2 Sens Dfp_FrmMngRxEngTmp2 Sens Dfp_FrmMngRxEngTmp2 Sens Dfp_FrmMngTODashDspl Dfp_FrmMngTOEBC1 Dfp_FrmMngTOERC1DR error path of power stage fan 2 actuator error path of power stage fan 2 actuator error path of fan speed sensor signal error path of fan speed sensor signal Fuel filter fouling switch Fuel filter fouling switch Fuel filter fouling switch Fault path for fuel filter heating output Fault path for fuel filter heating output Water in fuel sensor Water in fuel sensor Fuel filter fouling detection Dfp for Water Detection Sensor Dfp for Heater used in EGR Mass Flow rate Dfp for Heater used in EGR Mass Flow rate Dfp for Heater used in EGR Mass Flow rate Dfp for Heater used in EGR Mass Flow rate Dfp for Recirculated Engine Exhaust Gas Temperature sensor Dfp for Recirculated Engine Exhaust Gas Temperature sensor Dfp for Recirculated Engine Exhaust Gas Temperature sensor Dfp for Recirculated Engine Exhaust Gas Temperature sensor Dfp for message DashDspl Faults of CAN message EBC1 Dfp for message ERC1DR 02 Weichai 1071 0042F Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 1071 1071 1639 1639 95 95 95 520207 520207 97 97 95 97 520208 520208 520208 520208 520209 0042F 0042F 00667 00667 0005F 0005F 0005F 7F00F 7F00F 00061 00061 0005F 00061 7F010 7F010 7F010 7F010 7F011 03 04 03 04 03 04 02 03 04 03 04 07 11 03 04 12 02 03 Weichai 520209 7F011 04 Weichai 520209 7F011 12 02 Weichai 520209 7F011 Weichai Weichai Weichai 520210 520211 520212 7F012 7F013 7F014 03 12 03 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 520213 520214 520215 520216 523218 523604 523222 520217 523605 523605 523606 523606 523607 523607 523608 523608 520218 520218 898 898 520 520 520219 520219 520220 520220 520237 520238 7F015 7F016 7F017 7F018 7FBD2 7FD54 7FBD6 7F019 7FD55 7FD55 7FD56 7FD56 7FD57 7FD57 7FD58 7FD58 7F01A 7F01A 00382 00382 00208 00208 7F01B 7F01B 7F01C 7F01C 7F02D 7F02E Dfp_FrmMngTOETC1 Dfp_FrmMngTOEngGsFl owRt Dfp_FrmMngTOHRVD Dfp_FrmMngTORxAMCO N Dfp_FrmMngTORxCCVS Dfp_FrmMngTORxEngTe mp2 Dfp_FrmMngTOTCO1 Dfp_FrmMngTOTF Dfp_FrmMngTOTSC1AE Dfp_FrmMngTOTSC1AE Dfp_FrmMngTOTSC1AR Dfp_FrmMngTOTSC1AR Dfp_FrmMngTOTSC1DE Dfp_FrmMngTOTSC1DE Dfp_FrmMngTOTSC1DR Dfp_FrmMngTOTSC1DR Dfp_FrmMngTOTSC1PE Dfp_FrmMngTOTSC1PE Dfp_FrmMngTOTSC1TE Dfp_FrmMngTOTSC1TE Dfp_FrmMngTOTSC1TR Dfp_FrmMngTOTSC1TR Dfp_FrmMngTOTSC1VE Dfp_FrmMngTOTSC1VE Dfp_FrmMngTOTSC1VR Dfp_FrmMngTOTSC1VR Dfp_FrmMngTOTimeDate Dfp_FrmMngTOWSI Faults of CAN message ETC1 Dfp for CAN message EngGsFlowRt Dfp timeout for message HRVD Df p for message RxAMCON Dfp for Time-out error of RxCCVS message Dfp for CAN message RxEngTemp2 Faults of CAN message TCO1 Dfp for message TF Dfp for messages TSC1AE Dfp for messages TSC1AE Dfp for message TSC1AR Dfp for message TSC1AR Dfp for messages TSC1DE Dfp for messages TSC1DE Dfp for message TSC1DR Dfp for message TSC1DR Dfp for message TSC1PE Dfp for message TSC1PE Dfp for messages TSC1TE Dfp for messages TSC1TE Dfp for message TSC1TR Dfp for message TSC1TR Dfp for messages TSC1VE Dfp for messages TSC1VE Dfp for message TSC1VR Dfp for message TSC1VR Dfp timeout for message TimeDate Faults of CAN message WSI 12 12 03 03 12 12 12 03 11 12 11 12 11 12 11 12 03 04 11 12 11 12 03 12 03 12 03 12 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 523500 520221 624 624 624 624 624 624 624 624 624 624 624 624 523617 630 630 630 630 520222 520222 520222 523612 523612 520224 520224 105 7FCEC 7F01D 00270 00270 00270 00270 00270 00270 00270 00270 00270 00270 00270 00270 7FD61 00276 00276 00276 00276 7F01E 7F01E 7F01E 7FD5C 7FD5C 7F020 7F020 00069 Dfp_FrmMngTxTO Dfp_GearbxIncMax Dfp_Gen1 指示灯1故障 Dfp_Gen1 指示灯1故障 Dfp_Gen1 指示灯1故障 Dfp_Gen1 指示灯1故障 Dfp_Gen2 指示灯2故障 Dfp_Gen2 指示灯2故障 Dfp_Gen2 指示灯2故障 Dfp_Gen2 指示灯2故障 Dfp_Gen3 指示灯3故障 Dfp_Gen3 指示灯3故障 Dfp_Gen3 指示灯3故障 Dfp_Gen3 指示灯3故障 Dfp_HWEMonCom Dfp_HWEMonEEPROM EEPROM错误 Dfp_HWEMonEEPROM EEPROM错误 Dfp_HWEMonEEPROM EEPROM错误 Dfp_HWEMonEEPROM EEPROM错误 Dfp_HWEMonRcyLocked Dfp_HWEMonRcySuppre ssed Dfp_HWEMonRcyVisible Dfp_HWEMonUMaxSuppl y Dfp_HWEMonUMinSuppl y Dfp_IAHSCD 空气湿度传感器故障 Dfp_IAHSCD 空气湿度传感器故障 Dfp_IATSCD 进气温度传感器 Faults in CAN send messages physical plausibility TSC Power Stage fault status for Generic Lamp 1 Power Stage fault status for Generic Lamp 1 Power Stage fault status for Generic Lamp 1 Power Stage fault status for Generic Lamp 1 Power Stage fault status for Generic Lamp 2 Power Stage fault status for Generic Lamp 2 Power Stage fault status for Generic Lamp 2 Power Stage fault status for Generic Lamp 2 Power Stage fault status for Generic Lamp 3 Power Stage fault status for Generic Lamp 3 Power Stage fault status for Generic Lamp 3 Power Stage fault status for Generic Lamp 3 error state communication - SPI error state of EEPROM error state of EEPROM error state of EEPROM EEPROM使用替代值 error path for Recovery which is locked error path for Recovery which is suppressed error path for Recovery which is visible error state supply voltage CJ940 upper limit error state supply voltage CJ940 lower limit error path of air humidity sensor error path of air humidity sensor error path of air temperature sensor 12 02 03 04 12 02 03 04 12 02 03 04 12 02 11 04 12 02 14 14 14 03 04 03 04 03 Weichai Weichai Weichai Weichai Weichai Weichai 105 105 520225 520225 520225 523350 00069 00069 7F021 7F021 7F021 7FC56 Weichai 523350 7FC56 Weichai 523350 7FC56 Weichai 523350 7FC56 Weichai 523351 7FC57 Weichai 523351 7FC57 Weichai 523351 7FC57 Weichai 523351 7FC57 Dfp_IATSCD 进气温度传感器 Dfp_IATSCD 进气温度传感器 Dfp_InjCrv_InjLim 理想喷油次数受限制 Dfp_InjCrv_InjLim 理想喷油次数受限制 Dfp_InjCrv_InjLim 理想喷油次数受限制 Dfp_InjVlvBnk1A 1、2、3缸中某喷油器短 路 Dfp_InjVlvBnk1A 1、2、3缸中某喷油器短 路 Dfp_InjVlvBnk1A 1、2、3缸中某喷油器短 路 Dfp_InjVlvBnk1A 1、2、3缸中某喷油器短 路 Dfp_InjVlvBnk1B 1、2、3缸中某喷油器断 路 Dfp_InjVlvBnk1B 1、2、3缸中某喷油器断 路 Dfp_InjVlvBnk1B 1、2、3缸中某喷油器断 路 Dfp_InjVlvBnk1B 1、2、3缸中某喷油器断 路 error path of air temperature sensor error path of air temperature sensor Fault path of injection limitation Fault path of injection limitation Fault path of injection limitation faultpath bank1-specific errors -> stop engine faultpath bank1-specific errors -> stop engine faultpath bank1-specific errors -> stop engine faultpath bank1-specific errors -> stop engine faultpath bank1-specific warnings -> stop engine faultpath bank1-specific warnings -> stop engine faultpath bank1-specific warnings -> stop engine faultpath bank1-specific warnings -> stop engine 04 12 16 15 11 03 04 11 11 11 11 12 11 03 Weichai 523352 7FC58 Dfp_InjVlvBnk2A faultpath bank2-specific 4、5、6缸中某喷油器短路 errors -> stop engine Dfp_InjVlvBnk2A faultpath bank2-specific 4、5、6缸中某喷油器短路 errors -> stop engine Dfp_InjVlvBnk2A faultpath bank2-specific 4、5、6缸中某喷油器短路 errors -> stop engine Dfp_InjVlvBnk2A faultpath bank2-specific 4、5、6缸中某喷油器短路 errors -> stop engine Dfp_InjVlvBnk2B 4、5、6缸中某喷油器断 路 Dfp_InjVlvBnk2B 4、5、6缸中某喷油器断 路 Dfp_InjVlvBnk2B 4、5、6缸中某喷油器断 路 faultpath bank2-specific warnings -> stop engine faultpath bank2-specific warnings -> stop engine faultpath bank2-specific warnings -> stop engine Weichai 523352 7FC58 04 Weichai 523352 7FC58 11 Weichai 523352 7FC58 11 Weichai 523353 7FC59 11 Weichai 523353 7FC59 11 Weichai 523353 7FC59 12 Weichai 523353 7FC59 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 523354 523354 523354 523354 523355 523355 523355 523355 651 7FC5A 7FC5A 7FC5A 7FC5A 7FC5B 7FC5B 7FC5B 7FC5B 0028B Dfp_InjVlvBnk2B 4、5、6缸中某喷油器断 路 Dfp_InjVlvChipA CY33X 系统配置错误 Dfp_InjVlvChipA CY33X 系统配置错误 Dfp_InjVlvChipA CY33X 系统配置错误 Dfp_InjVlvChipA CY33X 系统配置错误 Dfp_InjVlvChipB CY33X 系统内部程序错误 Dfp_InjVlvChipB CY33X 系统内部程序错误 Dfp_InjVlvChipB CY33X 系统内部程序错误 Dfp_InjVlvChipB CY33X 系统内部程序错误 Dfp_InjVlvCyl1A 喷油器1短路 Dfp_InjVlvCyl1A 喷油器1短路 Dfp_InjVlvCyl1A 喷油器1短路 Dfp_InjVlvCyl1A 喷油器1短路 Dfp_InjVlvCyl1B 喷油器1开路 Dfp_InjVlvCyl1B 喷油器1开路 Dfp_InjVlvCyl1B 喷油器1开路 Dfp_InjVlvCyl1B 喷油器1开路 Dfp_InjVlvCyl2A 喷油器2短路 Dfp_InjVlvCyl2A 喷油器2短路 Dfp_InjVlvCyl2A 喷油器2短路 Dfp_InjVlvCyl2A 喷油器2短路 Dfp_InjVlvCyl2B 喷油器2开路 Dfp_InjVlvCyl2B 喷油器2开路 faultpath bank2-specific warnings -> stop engine faultpath Chip-specific errors -> stop engine faultpath Chip-specific errors -> stop engine faultpath Chip-specific errors -> stop engine faultpath Chip-specific errors -> stop engine faultpath Chip-specific errors -> stop engine faultpath Chip-specific errors -> stop engine faultpath Chip-specific errors -> stop engine faultpath Chip-specific errors -> stop engine faultpath cylinder1specific errors -> stop engine faultpath cylinder1specific errors -> stop engine faultpath cylinder1specific errors -> stop engine faultpath cylinder1specific errors -> stop engine faultpath cylinder1specific warnings faultpath cylinder1specific warnings faultpath cylinder1specific warnings faultpath cylinder1specific warnings faultpath cylinder2specific errors -> stop engine faultpath cylinder2specific errors -> stop engine faultpath cylinder2specific errors -> stop engine faultpath cylinder2specific errors -> stop engine faultpath cylinder2specific warnings faultpath cylinder2specific warnings 11 03 04 12 02 03 04 12 02 03 Weichai 651 0028B 11 08 Weichai 651 0028B Weichai 651 0028B 11 11 11 12 11 03 Weichai Weichai Weichai Weichai Weichai 651 651 651 651 652 0028B 0028B 0028B 0028B 0028C Weichai 652 0028C 11 08 Weichai 652 0028C Weichai 652 0028C 11 11 11 Weichai Weichai 652 652 0028C 0028C Weichai Weichai Weichai 652 652 653 0028C 0028C 0028D Dfp_InjVlvCyl2B 喷油器2开路 Dfp_InjVlvCyl2B 喷油器2开路 Dfp_InjVlvCyl3A 喷油器3短路 Dfp_InjVlvCyl3A 喷油器3短路 Dfp_InjVlvCyl3A 喷油器3短路 Dfp_InjVlvCyl3A 喷油器3短路 Dfp_InjVlvCyl3B 喷油器3开路 Dfp_InjVlvCyl3B 喷油器3开路 Dfp_InjVlvCyl3B 喷油器3开路 Dfp_InjVlvCyl3B 喷油器3开路 Dfp_InjVlvCyl4A 喷油器4短路 Dfp_InjVlvCyl4A 喷油器4短路 Dfp_InjVlvCyl4A 喷油器4短路 Dfp_InjVlvCyl4A 喷油器4短路 Dfp_InjVlvCyl4B 喷油器4开路 Dfp_InjVlvCyl4B 喷油器4开路 Dfp_InjVlvCyl4B 喷油器4开路 Dfp_InjVlvCyl4B 喷油器4开路 Dfp_InjVlvCyl5A 喷油器5短路 Dfp_InjVlvCyl5A 喷油器5短路 Dfp_InjVlvCyl5A 喷油器5短路 Weichai 653 0028D Weichai 653 0028D Weichai 653 0028D Weichai Weichai Weichai Weichai Weichai 653 653 653 653 654 0028D 0028D 0028D 0028D 0028E Weichai 654 0028E Weichai 654 0028E Weichai 654 0028E Weichai Weichai Weichai Weichai Weichai 654 654 654 654 655 0028E 0028E 0028E 0028E 0028F Weichai 655 0028F Weichai 655 0028F faultpath cylinder2specific warnings faultpath cylinder2specific warnings faultpath cylinder3specific errors -> stop engine faultpath cylinder3specific errors -> stop engine faultpath cylinder3specific errors -> stop engine faultpath cylinder3specific errors -> stop engine faultpath cylinder3specific warnings faultpath cylinder3specific warnings faultpath cylinder3specific warnings faultpath cylinder3specific warnings faultpath cylinder4specific errors -> stop engine faultpath cylinder4specific errors -> stop engine faultpath cylinder4specific errors -> stop engine faultpath cylinder4specific errors -> stop engine faultpath cylinder4specific warnings faultpath cylinder4specific warnings faultpath cylinder4specific warnings faultpath cylinder4specific warnings faultpath cylinder5specific errors -> stop engine faultpath cylinder5specific errors -> stop engine faultpath cylinder5specific errors -> stop engine 12 11 03 11 08 11 11 11 12 11 03 11 08 11 11 11 12 11 03 11 08 Weichai 655 0028F Dfp_InjVlvCyl5A 喷油器5短路 Dfp_InjVlvCyl5B 喷油器5开路 Dfp_InjVlvCyl5B 喷油器5开路 Dfp_InjVlvCyl5B 喷油器5开路 Dfp_InjVlvCyl5B 喷油器5开路 Dfp_InjVlvCyl6A 喷油器6短路 Dfp_InjVlvCyl6A 喷油器6短路 Dfp_InjVlvCyl6A 喷油器6短路 Dfp_InjVlvCyl6A 喷油器6短路 Dfp_InjVlvCyl6B 喷油器6开路 Dfp_InjVlvCyl6B 喷油器6开路 Dfp_InjVlvCyl6B 喷油器6开路 Dfp_InjVlvCyl6B 喷油器6开路 Weichai Weichai Weichai Weichai Weichai 655 655 655 655 656 0028F 0028F 0028F 0028F 00290 Weichai 656 00290 Weichai 656 00290 Weichai 656 00290 Weichai Weichai Weichai Weichai Weichai 656 656 656 656 520226 00290 00290 00290 00290 faultpath cylinder5specific errors -> stop engine faultpath cylinder5specific warnings faultpath cylinder5specific warnings faultpath cylinder5specific warnings faultpath cylinder5specific warnings faultpath cylinder6specific errors -> stop engine faultpath cylinder6specific errors -> stop engine faultpath cylinder6specific errors -> stop engine faultpath cylinder6specific errors -> stop engine faultpath cylinder6specific warnings faultpath cylinder6specific warnings faultpath cylinder6specific warnings faultpath cylinder6specific warnings 11 11 11 12 11 03 11 08 11 11 11 12 11 7F022 Weichai 520226 7F022 Weichai 520226 7F022 Weichai 520226 7F022 Weichai 596 00254 Weichai Weichai 1213 1213 004BD 004BD Dfp_InjVlvNumMinInj faultpath -The minimal 正常工作的气缸数小于最 number of injections was 12 not reached-> stop engine 小缸数 Dfp_InjVlvNumMinInj faultpath -The minimal 正常工作的气缸数小于最 number of injections was 255 not reached-> stop engine 小缸数 Dfp_InjVlvNumMinInj faultpath -The minimal 正常工作的气缸数小于最 number of injections was 255 not reached-> stop engine 小缸数 Dfp_InjVlvNumMinInj faultpath -The minimal 正常工作的气缸数小于最 number of injections was 255 not reached-> stop engine 小缸数 Dfp_MFLvCrCtlMode Dfp_MIL 故障灯故障 Dfp_MIL 故障灯故障 fault path for cruise control actuating device evaluation error Power Stage fault status for MIL Power Stage fault status for MIL 02 03 04 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 1213 1213 1485 1485 520227 520227 520227 2634 2634 523420 004BD 004BD 005CD 005CD 7F023 7F023 7F023 00A4A 00A4A Dfp_MIL 故障灯故障 Dfp_MIL 故障灯故障 Dfp_MRlyCD 主继电器2故障 Dfp_MRlyCD 主继电器2故障 Dfp_MSSCD 巡航开关故障 Dfp_MSSCD 巡航开关故障 Dfp_MSSCD 巡航开关故障 Dfp_MnRly1_SCB Dfp_MnRly1_SCG Power Stage fault status for MIL Power Stage fault status for MIL error path for main relay 2 error path for main relay 2 error path of multiple state switch error path of multiple state switch error path of multiple state switch error path for main relay 1 error path for main relay 1 the fault path contains the supervision of the communicationbetween Watchdog of CY310 and the controller. The path is used to handle the reversible Shut-down of the system using the engine coordinator Busoff in CAN A Busoff in CAN B Busoff in CAN C error path for engine oil level sensor error path for engine oil level sensor error path for engine oil level sensor error path for engine oil level sensor error path of oil pressure sensor error path of oil pressure sensor error path of oil pressure sensor error path of oil pressure sensor error path for oil pressure too low error error path of oil temperature sensor error path of oil temperature sensor error path of oil temperature sensor 12 02 03 04 03 04 02 03 04 02 7FC9C Dfp_Montr Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 639 1231 1235 98 98 98 98 100 100 100 100 100 175 175 175 0027F 004CF 004D3 00062 00062 00062 00062 00064 00064 00064 00064 00064 000AF 000AF 000AF Dfp_NetMngCANAOff Dfp_NetMngCANBOff Dfp_NetMngCANCOff Dfp_OLSCD 机油液位传感器故障 Dfp_OLSCD 机油液位传感器故障 Dfp_OLSCD 机油液位传感器故障 Dfp_OLSCD 机油液位传感器故障 Dfp_OPSCD 机油压力传感器故障 Dfp_OPSCD 机油压力传感器故障 Dfp_OPSCD 机油压力传感器故障 Dfp_OPSCD 机油压力传感器故障 Dfp_OPSCD1 Dfp_OTSCD 机油温度传感器故障 Dfp_OTSCD 机油温度传感器故障 Dfp_OTSCD 机油温度传感器故障 12 12 12 03 04 12 02 03 04 12 02 17 03 04 12 Weichai Weichai 175 175 000AF 000AF Dfp_OTSCD 机油温度传感器故障 Dfp_OTSCD1 Dfp_OvRMon Dfp_OvRMonSigA Dfp_PCRGvnrDvtMax Dfp_PCRGvnrDvtMin Dfp_PSPCD_Actr 电动燃油泵故障 Dfp_PSPCD_Actr 电动燃油泵故障 Dfp_PSPCD_Actr 电动燃油泵故障 Dfp_PSPCD_Actr 电动燃油泵故障 Dfp_RunUpTst Dfp_SOPTst 冗余断缸测试故障 Dfp_SOPTst 冗余断缸测试故障 Dfp_SOPTst 冗余断缸测试故障 Dfp_SSpMon1 传感器电源1电压超出门槛 值 Dfp_SSpMon1 传感器电源1电压超出门槛 值 Dfp_SSpMon2 传感器电源2电压超出门槛 值 Dfp_SSpMon2 传感器电源2电压超出门槛 值 Dfp_SSpMon3 传感器电源3电压超出门槛 值 Dfp_SSpMon3 传感器电源3电压超出门槛 值 Dfp_ShOffTst Dfp_SysLamp 系统灯故障 Dfp_SysLamp 系统灯故障 Weichai Weichai 1108 520228 00454 7F024 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 520229 520230 520231 520231 520231 520231 520232 970 7F025 7F026 7F027 7F027 7F027 7F027 7F028 003CA error path of oil temperature sensor error path of oil temperature sensor for above normal error Fault path of overrun monitoring Fault path for redundant engine speed calculation in overrun monitoring Permanent governor deviation in PCR Permanent governor deviation in PCR error path of power stage pre-supply pump error path of power stage pre-supply pump error path of power stage pre-supply pump error path of power stage pre-supply pump faultpath for runup test Fault path for test of redundant shut off paths during initialization Fault path for test of redundant shut off paths during initialization Fault path for test of redundant shut off paths during initialization sensor supply voltage 1 02 17 16 15 15 17 03 04 12 02 255 12 03 Weichai 970 003CA Weichai 970 003CA 04 Weichai 1079 00437 03 Weichai 1079 00437 04 sensor supply voltage 1 03 sensor supply voltage 2 04 sensor supply voltage 2 03 sensor supply voltage 3 04 sensor supply voltage 3 faultpath for shut off test Power Stage fault status for System lamp Power Stage fault status for System lamp 20 03 04 Weichai 1080 00438 Weichai 1080 00438 Weichai 523601 7FD51 Weichai 523601 7FD51 Weichai Weichai Weichai 520233 624 624 7F029 00270 00270 Weichai Weichai Weichai 624 624 158 00270 00270 0009E Dfp_SysLamp 系统灯故障 Dfp_SysLamp 系统灯故障 Dfp_T15CD Weichai 1041 00411 Dfp_T50CD Dfp_TPUMon Dfp_TVACD_Max Power Stage fault status for System lamp Power Stage fault status for System lamp error path for terminal 15 - contains plausibility error [Sig] of T15 fault path for Terminal 50 component driver T50CD TPU monitoring fault path for short circuit to battery for TVA power stage fault path for short circuit to ground for TVA power stage fault path for no load and excess temparature for TVA power stage fault path for no load and excess temparature for TVA power stage fault path 1 for vehicle speed sensing fault path 1 for vehicle speed sensing fault path 1 for vehicle speed sensing fault path 1 for vehicle speed sensing fault path 2 for vehicle speed sensing fault path 2 for vehicle speed sensing fault path 2 for vehicle speed sensing fault path 2 for vehicle speed sensing fault path 3 for vehicle speed sensing fault path 3 for vehicle speed sensing fault path 3 for vehicle speed sensing Errorpath for dataset variant coding, Npl=Requested variant could not be set, Sig=variant dataset defect 12 02 12 07 Weichai Weichai 523550 520234 7FD1E 7F02A 02 03 Weichai 520234 7F02A Dfp_TVACD_Min Dfp_TVACD_SigNpl 空气节流阀信号不可信 Dfp_TVACD_SigNpl 空气节流阀信号不可信 Dfp_VSSCD1 车速1信号不可信 Dfp_VSSCD1 车速1信号不可信 Dfp_VSSCD1 车速1信号不可信 Dfp_VSSCD1 车速1信号不可信 Dfp_VSSCD2 车速2信号不可信 Dfp_VSSCD2 车速2信号不可信 Dfp_VSSCD2 车速2信号不可信 Dfp_VSSCD2 车速2信号不可信 Dfp_VSSCD3 车速3信号不可信 Dfp_VSSCD3 车速3信号不可信 Dfp_VSSCD3 车速3信号不可信 04 Weichai 520234 7F02A 12 02 Weichai 520234 7F02A Weichai Weichai Weichai Weichai 84 84 84 84 00054 00054 00054 00054 00 11 12 02 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 1624 1624 1624 1624 645 645 645 520239 00658 00658 00658 00658 00285 00285 00285 03 04 12 02 03 04 12 7F02F Dfp_VarMngCodDs 11 Weichai 520239 7F02F Dfp_VarMngCodDs Weichai 523600 7FD50 Dfp_WdCom Dfp_Wrn 故障指示灯故障 Dfp_Wrn 故障指示灯故障 Dfp_Wrn 故障指示灯故障 Dfp_Wrn 故障指示灯故障 Dfp_ACCDCmpr 空调压缩机故障 Dfp_ACCDCmpr 空调压缩机故障 Dfp_ACCDCmpr 空调压缩机故障 Dfp_ACCDCmpr 空调压缩机故障 Dfp_BPACD_ADC BPA信号故障 Dfp_BPACD_ADC BPA信号故障 Dfp_BPACD_ADC BPA信号故障 Dfp_HpTst Dfp_MeUnCDNoLoad Dfp_MeUnCDNoLoad Dfp_MeUnCDSCBat Dfp_MeUnCDSCGnd Dfp_MeUnCD_ADC Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai 624 624 624 624 1351 1351 1351 1351 1192 00270 00270 00270 00270 00547 00547 00547 00547 004A8 Weichai 1192 004A8 Weichai 1192 004A8 Errorpath for dataset variant coding, Npl=Requested variant could not be set, Sig=variant dataset defect the fault path contains the supervision of the SPIHandler Power Stage fault status for Warning Lamp Power Stage fault status for Warning Lamp Power Stage fault status for Warning Lamp Power Stage fault status for Warning Lamp Fault path of air condition power stage Fault path of air condition power stage Fault path of air condition power stage Fault path of air condition power stage error path of boost pressure actuator current AD-channel error path of boost pressure actuator current AD-channel error path of boost pressure actuator current AD-channel HpTst error path of metering unit PWM-powerstage error path of metering unit PWM-powerstage error path of metering unit PWM-powerstage error path of metering unit PWM-powerstage 02 12 03 04 12 02 03 04 12 02 03 04 12 20 05 02 03 04 Weichai Weichai Weichai Weichai Weichai Weichai 520223 523615 523615 523615 523615 523615 7F01F 7FD5F 7FD5F 7FD5F 7FD5F 7FD5F error path of metering unit 16 AD-channel error path of metering unit 18 AD-channel error path of rail pressure 00 relief valve error path of rail pressure 11 relief valve Weichai 523615 7FD5F Dfp_MeUnCD_ADC Dfp_PRVMon 共轨泻压阀打开 Dfp_PRVMon 共轨泻压阀打开 Weichai Weichai 523470 523470 7FCCE 7FCCE Weichai Weichai Weichai Weichai Weichai Weichai 523470 157 157 157 157 523613 7FCCE 0009D 0009D 0009D 0009D 7FD5D Dfp_PRVMon 共轨泻压阀打开 Dfp_RailCD 轨压传感器故障 Dfp_RailCD 轨压传感器故障 Dfp_RailCDOfsTst 轨压传感器电压偏差超限 Dfp_RailCDOfsTst 轨压传感器电压偏差超限 Dfp_RailMeUn0 error path of rail pressure 07 relief valve 03 error path of rail pressure error path of rail pressure error path RPS offset monitoring error path RPS offset monitoring 04 15 17 faults for checks in MeUn 16 controlled mode faults for checks in MeUn 15 controlled mode Weichai 523613 7FD5D Dfp_RailMeUn1 Weichai 523613 7FD5D Dfp_RailMeUn2 faults for checks in MeUn 17 controlled mode faults for checks in MeUn controlled mode faults for checks in MeUn controlled mode faults for checks in MeUn controlled mode faults for checks in MeUn controlled mode faults for checks in MeUn controlled mode 05 7FD5D Dfp_RailMeUn12 Dfp_SSpMon12V 12V传感器电源电压故障 Dfp_SSpMon12V 12V传感器电源电压故障 Dfp_StrtCDHS 起动电机高端故障 Dfp_StrtCDHS 起动电机高端故障 faults for checks in MeUn controlled mode 12V sensor supply voltage 12V sensor supply voltage fault path for short circuit to batery or ground for high power stage fault path for short circuit to batery or ground for high power stage fault path for short circuit to batery or ground, no load, or excess temparature for low side power stage 03 04 03 04 03 18 02 07 7FD5D Dfp_RailMeUn10 Weichai Weichai Weichai Weichai Weichai 523613 523613 523613 523613 523613 7FD5D 7FD5D 7FD5D 7FD5D Dfp_RailMeUn3 Dfp_RailMeUn4 Dfp_RailMeUn6 Dfp_RailMeUn7 Weichai 523613 Weichai Weichai Weichai 520235 520235 677 7F02B 7F02B 002A5 Weichai 677 002A5 04 Weichai 677 002A5 Dfp_StrtCDLS 起动电机低端故障 03 Weichai 677 002A5 Dfp_StrtCDLS 起动电机低端故障 Weichai 677 002A5 Dfp_StrtCDLS 起动电机低端故障 Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai Weichai SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 22 22 22 22 22 42 42 42 42 42 42 37 37 37 110 110 523613 520242 520241 520240 520243 520243 520243 520244 520244 520244 0006E 0006E 7FD5D 7F032 7F031 7F030 7F033 7F033 7F033 7F034 7F034 7F034 00122 00123 00222 00223 00121 00221 00120 00220 02120 02163 02109 00238 00237 00236 Dfp_CTSCDOvrTemp Dfp_CTSCDOvrTemp dfp_railmeun8 dfp_brk1swterr dfp_brk1swtcrctlrls dfp_brk1swtcrctllmp dfp_rmtapp1 dfp_rmtapp1 dfp_rmtapp1 dfp_rmtapp2 dfp_rmtapp2 dfp_rmtapp2 Accel Pedal Sensor No.1 Signal Too low Accel Pedal Sensor No.1 Signal Too high Accel Pedal Sensor No.2 Signal Too low Accel Pedal Sensor No.2 Signal Too high Accel Pedal Sensor No.1 not close Accel Pedal Sensor No.2 not close Accel Pedal Sensor No.1 not open Accel Pedal Sensor No.2 not open Both Accel Pedal Sensor Signal Invalid Idle switch stuck opened Idle switch stuck closed Boost Pressure Sensor Signal Too High Boost Pressure Sensor Signal Too Low Boost Pressure Sensor Performance Invalid fault path for short circuit to batery or ground, no load, or excess temparature for low side power stage fault path for short circuit to batery or ground, no load, or excess temparature for low side power stage error path of over coolant temperature error path of over coolant temperature 04 05 15 15 13 02 02 02 03 04 02 03 04 02 P0122 P0123 P0222 P0223 P0121 P0221 P0120 P0220 P2120 P2163 P2109 P0238 P0237 P0236 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 23 23 67 67 67 00227 00228 00193 00192 00191 26 26 11 11 14 14 16 16 15 15 44 44 45 13 12 13 21 21 21 28 00563 00562 00118 00117 00183 00182 00113 00112 02229 02228 01143 01142 00617 00337 00342 00385 00503 00502 00501 01681 PTO Accel Pedal Sensor Signal Too low PTO Accel Pedal Sensor Signal Too high Common Rail Pressure Sensor Signal Too High Common Rail Pressure Sensor Signal Too low Common Rail Pressure Sensor Signal keeping the middle range Vehicle System Voltage Too High Vehicle System Voltage Too low Coolant Temperature Sensor Signal Too High Coolant Temperature Sensor Signal Too low Fuel Temperature Sensor Signal Too High Fuel Temperature Sensor Signal Too low Intake Air Temperature Sensor Signal Too High Intake Air Temperature Sensor Signal Too low Atom Pressure Sensor Signal Too High Atom Pressure Sensor Signal Too low IMC Volume Signal Too High IMC Volume Signal Too Low Starter Switch Short to BATT Crank Sensor No Pulse Cam Sensor No Pulse Crank & Cam Sensor No Pulse Vehicle Speed Sensor Frequency Too High Vehicle Speed Sensor Input Open / Short Vehicle Speed Sensor Signal Invalid Exhaust Brake MV1 Output Open Load/Short to GND Exhaust Brake MV1 Output Short to BATT P0227 P0228 P0193 P0192 P0191 P0563 P0562 P0118 P0117 P0183 P0182 P0113 P0112 P2229 P2228 P1143 P1142 P0617 P0337 P0342 P0385 P0503 P0502 P0501 P1681 28 01682 P1682 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 57 02148 57 02147 57 02146 58 02151 58 02150 58 02149 51 55 53 56 52 54 59 00201 00205 00203 00206 00202 00204 00611 59 00200 74 00629 75 00627 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 75 01190 78 00093 79 79 02293 01217 COM1 output short to BATT TWV1or3or5 output short to BATT COM1 output short to GND TWV1or3or5 output short to GND COM1 output open load Both TWV1 and TWV3 and TWV5 open load COM2 output short to BATT TWV2or4or6 output short to BATT COM2 output short to GND TWV2or4or6 output short to GND COM2 output open load Both TWV2 and TWV4 and TWV6 open load TWV1 output open load Injector coil open TWV2 output open load Injector coil open TWV3 output open load Injector coil open TWV4 output open load Injector coil open TWV5 output open load Injector coil open TWV6 output open load Injector coil open Capacitor charge-up circuit malfunction (insufficient charge) Capacitor charge-up circuit malfunction (excessive charge) SCV( ) output short to BATT; SCV(-) output short to BATT SCV( ) output Open Load/short to GND ; SCV(-) output Open Load/short to GND ; SCV coil open Supply pump control valve (suction control valve) stuck Common Rail Pressure Sensor Performance Invalid included fuel leak Supply pump protection Supply pump exchange P2148 P2147 P2146 P2151 P2150 P2149 P0201 P0205 P0203 P0206 P0202 P0204 P0611 P0200 P0629 P0627 P1190 P0093 P2293 P1217 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 77 77 69 68 61 65 63 66 62 64 7 25 25 46 6 39 39 48 48 9 9 41 01218 01219 01089 00088 00301 00302 00303 00304 00305 00306 00219 00541 00542 01530 00217 00234 00299 01676 01677 00073 01001 00704 Supply pump malfunction P1218 (insufficient flow) pressure limiter activated P1219 Common rail pressure exceeds upper limit Common rail pressure exceeds hi upper limit Cylinder 1 fuel system falure Cylinder 2 fuel system falure Cylinder 3 fuel system falure Cylinder 4 fuel system falure Cylinder 5 fuel system falure Cylinder 6 fuel system falure Engine overrun Glow Relay Output Short to GND Glow Relay Output Open Load/Short to BATT Engine Stop switch stuck closed Coolant Temp. exceeds upper limit Boost Pressure Sensor exceeds upper limit Boost Pressure Sensor exceeds lower limit 1st/Rev SW Open Load/Short to GND 1st/Rev SW Output Short to BATT CAN1 Node Error CAN2 Node Error Clutch Switch Circuit Malfunction (manual transmission only) Neutral Switch Circuit Malfunction (manual transmission only) F/D (Flow Damper) #1 activated F/D (Flow Damper) #2 activated F/D (Flow Damper) #3 activated P1089 P0088 P0301 P0302 P0303 P0304 P0305 P0306 P0219 P0541 P0542 P1530 P0217 P0234 P0299 P1676 P1677 U0073 U1001 P0704 47 00850 P0850 61 65 63 00263 00275 00269 P0263 P0275 P0269 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 SDEC SC9DFQ3 66 62 64 9 9 9 5 43 2 2 0 00278 00266 00272 00101 00121 00155 00686 01565 01602 00602 01601 F/D (Flow Damper) #4 activated F/D (Flow Damper) #5 activated F/D (Flow Damper) #6 activated Can Bus-Line Open From AT Can Bus-Line Open From ABS Can Bus-Line Open From METER Main relay diagnostics; Main relay stuck closed Cruise SW Circuit Malfunction QR data is not written QR data Error QR definition error (Definition concerning QR correction is not right) CPU fault; -Watchdog IC fault CPU fault; -Main CPU fault check sum error - Flash area Engine Oil Pressure Sensor too High Engine Oil Pressure Sensor too Low Engine Oil Pressure Down Coolant Level Low Bleeder Brake MV1 Output Open Load/Short to GND Bleeder Brake MV1 Output Short to BATT Bleeder Brake MV2 Output Open Load/Short to GND Bleeder Brake MV2 Output Short to BATT SCV coil short P0278 P0266 P0272 U0101 U0121 U0155 P0686 P1565 P1602 P0602 P1601 3 3 3 18 18 18 49 29 00607 00606 00601 00523 00522 00524 02560 01683 P0607 P0606 P0601 P0523 P0522 P0524 P2560 P1683 29 29 01684 01685 P1684 P1685 29 0 19 01686 0062A 02269 P1686 P062A Water in fuel filter failure P2269 燃油过滤器内有水的故障 FMI Description FMI描述 气隙调整不当 说明 调整传感器与齿圈的间隙0.8-1.2 轮胎或齿圈不正确 数据出厂设定或用户自换轮胎尺寸问题 传感器极柱短接 接地或短路 开路 短路 不正确的齿圈 检查传感器接线 检查接线短路或搭铁 检查接线断路 检查传感器信号线与地线之间短路 齿圈滑动 电线错接 调整气隙 速度异常（咔哒作响） 频率太高 气隙调整不当 检查间隙过小或齿圈间隙处有铁屑 检查ABS线路分错 调整传感器与齿圈的间隙0.8-1.2 调整传感器与齿圈的间隙0.8-1.2 调整传感器与齿圈的间隙0.8-1.2 轮胎或齿圈不正确 数据出厂设定或用户自换轮胎尺寸问题 传感器极柱短接 检查传感器接线 接地短路 开路 短路 不正确的齿圈 检查接线短路或搭铁 检查接线断路 检查传感器信号线与地线之间短路 齿圈滑动 电线错接 调整气隙 速度异常（咔哒作响） 检查间隙过小或齿圈间隙处有铁屑 检查ABS线路分错 调整传感器与齿圈的间隙0.8-1.2 调整传感器与齿圈的间隙0.8-1.2 频率太高 气隙调整不当 调整传感器与齿圈的间隙0.8-1.2 轮胎或齿圈不正确 数据出厂设定或用户自换轮胎尺寸问题 传感器极柱短接 检查传感器接线 接地短路 开路 短路 不正确的齿圈 检查接线短路或搭铁 检查接线断路 检查传感器信号线与地线之间短路 齿圈滑动 电线错接 调整气隙 速度异常（咔哒作响） 频率太高 气隙调整不当 检查间隙过小或齿圈间隙处有铁屑 检查ABS线路分错 调整传感器与齿圈的间隙0.8-1.2 调整传感器与齿圈的间隙0.8-1.2 调整传感器与齿圈的间隙0.8-1.2 轮胎或齿圈不正确 数据出厂设定或用户自换轮胎尺寸问题 传感器极柱短接 检查传感器接线 接地短路 开路 短路 不正确的齿圈 检查接线短路或搭铁 检查接线断路 检查传感器信号线与地线之间短路 齿圈滑动 电线错接 检查间隙过小或齿圈间隙处有铁屑 检查ABS线路分错 调整气隙 速度异常（咔哒作响） 频率太高 与电源短接，检查接线柱 接线柱有断路 接地短路 与电源短接，检查接线柱 接线柱有断路 接地短路 与电源短接，检查接线柱 接线柱有断路 接地短路 与电源短接，检查接线柱 接线柱有断路 接地短路 与电源短接，检查接线柱 接线柱有断路 接地短路 电压过低或断路 检查 WL-接地端 检查ABS阀继电器 调整传感器与齿圈的间隙0.8-1.2 调整传感器与齿圈的间隙0.8-1.2 电压过低或断路，检查电源 线和接地线 电压过低或断路，检查电源 线和接地线 检查WL-接地 接地短路 阀继电器 电压过低或断路，检查电源 线和接地线 制动信号输入端断开或接地 短路 不同制动阀，与UBATT短接 不同的制动阀，开路 不同的制动阀，接地短路 UBATT挂车制动阀，与UBATT 短接 拖车制动阀，开路 拖车制动阀，与地线短接 警示灯接地 SAE J1939 VSC1速度可靠性 差 SAE J1939开路或短路 没有接入SAE J1939 SAE J1939 ERC_DR暂停 SAE J1939 ERC_ER (_EXR) 暂停 SAE J1939 ETC暂停 SAE J1939 EEC1暂停 SAE J 1939 ERC_EXR 暂停 SAE J1939, internal error SAE J1939内部错误 超电压 EEPROM 轮参数不正确 EPROM 校验和 电子w/o负载 当不能使用诊断仪检查时， 滑动检查时间超出 所有阀无信号，包括 ABS, 控制阀 参数错误 无 ABS，无闪码 调节器阀激活时间 多种可能 32V<V<36V 8V<V<18V V>36V V<8V 32V<V<36V 8V<V<18V V>36V V<8V 32V<V<36V 8V<V<18V V>36V V<8V 32V<V<36V 8V<V<18V V>36V V<8V 32V<V<36V 8V<V<18V V>36V V<8V 检查更换灯泡 I< IS I< IS I< IS I< IS I< IS I< IS I< IS I< IS I< IS I< IS 0.6V<(Vout/Vc)<1V 0.14V<(Vout/Vc)< 0.38V Vout/Vc>1V Vout/Vc<0.14V 0.6V<(Vout/Vc)<1V 0.14V<(Vout/Vc)< 0.38V Vout/Vc>1V Vout/Vc<0.14V 6V<V<8V 2V<V<4V V>8V V<2V 电压高于正常值（s.c.到蓄电 池或开路） l电压低于平常值 电压高于平常值 电压高于正常值（s.c.到蓄电 池或开路） 电压低于正常值（s.c.接地） 行驶记录仪看不到时间/日期 发动机从EDC启动模式不可 用 无法从EDC得到发动机机油 温度 EEPROM无法存储日期 EEPROM无法存储时间 EEPROM无法存储机油液面 电压高于正常值（s.c.到蓄电 池或开路） 电压低于正常值（s.c.接地） 车身电脑电源或搭铁断路或连接不好； CAN线断路 发动机EDC电源或搭铁断路或连接不 好；CAN线断路 行驶记录仪电源或搭铁断路或连接不 好；CAN线断路 无 ABS电源或搭铁断路或连接不好；CAN 线断路 无 无 无 信号过强 信号太弱 没有使用 检查接线是否短路 检查接线是否短路 检查接线是否接触不良 信号与参考信号不一致 信号不可靠 离合器信号没有通过CAN 信号不可靠 信号错误 信号不可靠 没有信号 电压过高 电压过低 CAN信号错误 电压不可靠 无效的信号组合 无效的信号结合 与蓄电池短接 检查接线可能接触不良，时断时续 离合器信号CAN总线传输错误 检查接线可能接触不良，时断时续 制动信号线断路或短路 检查接线可能接触不良，时断时续 没有T15信号 电压值超出上限值 电压值低于下限值 CAN信号错误 电压值超出上限门槛值 信号不可靠 信号不可靠 与电源短路 接地短路 信号过强 信号太弱 与蓄电池短接 接地短路 与蓄电池短接 与蓄电池短接 接地短路 与蓄电池短接或开路 接地短路 与蓄电池短接 接地短路 开路 与地短路 输出信号电压太高 输出信号电压太低 与电源短路 与地短路 与电源短路 与电源短路 与地短路 与电源短路或断路 与地短路 与电源短路 与地短路 断路 多元信号故障 继电器打开过早（启动后未 连接） 接地 信号故障 与地短路 信号太强 信号太弱 CAN 信号故障 机油温度信号不可靠 未达到最小温度上升 信号太强 信号太弱 CAN信号故障 信号太强 信号太弱 CAN 信号故障 信号不可靠 信号太强 信号太弱 信号太强 信号太弱 阀打开 要求的压力冲击（在正常的 开放的压力情况下阀没有打 开） 压力冲击后阀没有打开 信号太弱 信号太强 硬件故障 输出值太高 信号电压太高 信号电压太高 信号电压太低 CAN信号传输错误 信号不可信 信号电压太高 信号电压太低 CAN信号传输错误 信号电压太高 信号电压太低 CAN信号传输错误 信号不可信 信号电压太高 信号电压太低 信号电压太高 信号电压太低 控制阀常开 要求进行压力冲击（在正常的打开压力 下阀不能正常打开） 在受压力冲击后阀不能打开 信号电压太高 信号电压太低 硬件故障 输出值太高 信号电压太高 信号电压太低 CAN信号错误 冷却液温度信号不可靠 信号电压太低 CAN信号错误 信号不可信 Minimum Temperature not reached in time未及时达到最 低温度 值高于上限 轨压值超过上限门槛值 值低于下限 值太低 温度太高 没有信号 信号错误 后备模式 没有信号 信号错误 信号抵消 按钮卡死 按钮卡死 发动机超速运行 Test actuive 扭矩被限制 轨压值低于下限门槛值 输出值太低 温度太高 没有信号输出 信号错误 备用模式 没有信号输出 信号错误 转角信号偏置 按钮卡死 按钮卡死 发动机超速运行 测试被激活 扭矩被限制 扭矩被限制 扭矩被限制 扭矩被限制 扭矩被限制 扭矩被限制 扭矩被限制 燃油流量高于正偏差上限门 槛值 燃油压力太高导致监控单元 关闭 共轨压力太低 燃油流量高于正偏差上限门槛值 燃油压力太高导致监控单元关闭 共轨压力太低 共轨压力太高 轨压下降斜率高于预测值 监控单元设定的轨压不可信 燃油系统泄漏或者监控单元 关闭 开路 温度太高 与电源短路 对地短路 喷油器低电压端与与电源短 路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短 路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短 路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短 路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短 路 根据实际应用情况 喷油器高电压端与地短路 共轨压力太高 轨压下降斜率高于设定值 监控单元设定的轨压不可信 燃油系统泄漏或者监控单元关闭 开路 温度太高 与电源短路 对地短路 喷油器低电压端与与电源短路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 喷油器低电压端与与电源短 路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 标定数据没有对其区分 喷油器低电压端与与电源短路 根据实际应用情况 喷油器高电压端与地短路 标定数据没有对其区分 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 根据实际应用情况 根据实际应用情况 开路 根据实际应用情况 未达到喷射量 短路 低电压端与地短路 开路 根据实际应用情况 短路 低电压端与地短路 根据实际应用情况 根据实际应用情况 标定数据没有对其区分 标定数据没有对其区分 短路 低端与地短路 根据实际应用情况 标定数据没有对其区分 Internal reset - Clock Loss Voltage too low 解锁-ECU初始化 测试模式 SPI通讯错误 短路 低端与地短路 根据实际应用情况 标定数据没有对其区分 内部设置-时间丢失-电压值太低 解锁-ECU初始化 测试模式 SPI通讯错误 内部设置-时间丢失-电压值太 重新设置-时基丢失-电压值太低 低 解锁-ECU初始化 解锁-ECU初始化 测试模式 SPI通讯错误 Torque Limitation CAN Bus off CAN Bus off CAN Bus off CAN timeout CAN timeout CAN timeout 测试模式 SPI通讯错误 扭矩被限制 CAN传输中断 CAN传输中断 CAN传输中断 CAN传输超时 CAN传输超时 CAN传输超时 CAN timeout CJ940 Communication failure Read failure Write failure Default Value used Recovery occurred CAN传输超时 CJ940信息错误 读写数据功能失效 刷写数据功能失效 备用 锁定解除 Watchdog and Controller not 看门狗开关不可信 plausible Watchdog 看门狗 Supply Voltage too high Supply Voltage too low Time deviation between System and TPU Variant Dataset not valid Variant could not be set SPI Communication failure Reference Voltage too high Reference Voltage too low Test Impulse Error Queue Error Recovery occurred Recovery occurred Short to Battery Short to Ground 电源输入太高 电源输入太低 系统和TPU运行时间不符 变量数据设定不合理 变量设置功能失效 SPI通讯错误 电压太高 电压太低 测试程序错误 监控排列错误 抑制被解除 抑制被解除 与电源短路 对地短路 Injection disabled Injection Time too long Speed Signal not plausible Signal too high 喷油器异常 喷射时间太长 车速信号不可靠 信号电压太高 Signal too low 信号电压太低 Signal too high Signal too low Signal too high Signal too low Signal too high Signal too low 信号电压太高 信号电压太低 信号电压太高 信号电压太低 信号电压太高 信号电压太低 Supply Voltage CJ940 供给电源在CJ940之上 above Limit Supply Voltage CJ940 below 供给电源在CJ940之下 Limit Signal too high 信号电压太高 Signal too low CAN Signal failure Signal not plausible to Reference Pressure (Boost or Exhaust) Short to Battery or excess temperature Short to Ground 信号电压太低 CAN信号错误 信号不可信 与电源短路或温度过高 与地短路 Open Load 开路 CAN Msg. TimeOut error Non-Plausible CAN Msg. Value SRC-High error of ADC reference voltage SRC-Low error of ADC reference voltage Test impulse error ADC queue error Voltage above upper limit Voltage below lower limit airmass ADC raw value > threshold high 来自CAN的空调信号超时 来自CAN的空调信号不可信 模数转换器参考电压超出上限门槛值 模数转换器参考电压低于下限门槛值 模数转换器测试脉冲电压高出门槛值 一定时间内只有部分数据流被转换 HFM传感器进气温度电压值超出上限门槛 值 HFM传感器进气温度电压值低于下限门 槛值 HFM传感器平均电压值超出上限门槛值 airmass ADC raw value < threshold low HFM传感器平均电压值低于下限门槛值 airmass ratio is higher then threshold high 空气流量比超出上限门槛值 airmass ratio is lower then threshold low Voltage above upper limit 电压高于上限 Voltage below lower limit 电压低于下限 Voltage above upper limit 电压高于上限 Voltage below lower limit 电压低于下限 plausibility with APP2 violated Voltage above upper limit Voltage below lower limit plausibility with APP1 violated Voltage above upper limit 电压高于上限 Voltage below lower limit 电压低于下限 signal value from CAN not ok Not plausible with boost pressure sensor Short Circuit Battery 空气流量比低于下限门槛值 单元时间内的空气流量超出上限门槛值 单元时间内的空气流量低于下限门槛值 油门踏板1电压值高出上限门槛值 油门踏板1电压值低于下限门槛值 油门踏板1与油门踏板2的两倍的信号关 系不可信 油门踏板2电压值高出上限门槛值 油门踏板2电压值低于下限门槛值 油门踏板2与油门踏板1的1/2的信号关系 不可信 大气压力传感器电压高出上限门槛值 大气压力传感器电压低于下限门槛值 来自CAN的大气压力传感器信号不可信 大气压力传感器与进气压力传感器信号 不可信 车速限制指示灯电源短路 Short Circuit Ground 车速限制指示灯电源短路 No Load 车速限制指示灯没有信号 Excess Temperature 车速限制指示灯超外温 AccPed signal not plausible 油门与刹车信号不可信 Positive governor deviation 进气量调节器正偏差超过上限门槛值 above limit negative governor 进气量调节器负偏差低于下限门槛值 deviation below limit multi signal defect 进气加热常开故障 voltage difference exceeds the higher threshold voltage difference falls below the lower threshold voltage difference exceeds the higher threshold voltage difference falls below the lower threshold Short Circuit to Battery Short Circuit to Ground Short Circuit Battery 进气加热器开时电压高于上限门槛值 进气加热器开时电压低于下限门槛值 进气加热器闭时电压高于上限门槛值 进气加热器闭时电压低于下限门槛值 进气加热器对电源短路 进气加热器对地短路 增压执行器电源短路故障 Short Circuit Ground 增压执行器对地短路故障 No Load 增压器没有信号 Excess Temperature 增压器超温 Voltage above upper limit Voltage below lower limit 进气压力传感器电压超出上限门槛值 进气压力传感器电压低于下限门槛值 signal value from CAN not 来自CAN的进气压力传感器信号不可信 ok plausibility error 进气压力传感器与大气压力传感器信号 不可信 Voltage above upper limit 电池电压原始值超出上限门槛 Voltage below lower limit brake signal is defective brake signals not plausible Short Circuit to Battery 中冷器旁通阀对电源短路 Short Circuit to Ground 中冷器旁通阀对地短路 No Load 中冷器旁通阀没有信号 Voltage above upper limit Voltage below lower limit open circuit 开路 冷却水水位传感器电压超出上限门槛值 冷却水水位传感器电压低于下限门槛值 冷却水位传感器开路 电池电压原始值低于下限门槛 来自CAN的刹车信号不可信 刹车主、辅开关信号不可信 plausibility error Short Circuit Battery Short Circuit Ground No Load Excess Temperature Short Circuit Battery 冷却水水位传感器信号不可信 CRERCD电源短路 CRERCD地短路 CRERCD没有信号 CRERCD超温 冷启动指示灯对电源短路 Short Circuit Ground No Load Excess Temperature Voltage above upper limit 冷启动指示灯对地短路 没有冷启动指示灯信号 冷启动指示灯超温 冷却水温度传感器电压超出上限门槛 Voltage below lower limit 冷却水温度传感器电压低于下限门槛 Can Msg. value defect 来自CAN的冷却水温度传感器信号不可 信 plausibility defect between OTS and CTS 冷却水温与油温信号不可信 Minimum temperature not 冷却水温在一定时间内没有达到最小值 reached within time limit Minimum temperature raise 冷却水温在一定时间内上升幅度没有达 not reached within time limit 到最小值 number of recognized misfire events above limit number of recognized misfire events above limit number of recognized misfire events above limit number of recognized misfire events above limit number of recognized misfire events above limit number of recognized misfire events above limit number of recognized misfire events above limit physical unplausibility of DCS-demand 气缸1失火次数超过门槛值 气缸2失火次数超过门槛值 气缸3失火次数超过门槛值 气缸4失火次数超过门槛值 气缸5失火次数超过门槛值 气缸6失火次数超过门槛值 多缸失火次数超过门槛值 发动机控制单元内部错误 压缩测试故障 CAN clutch signal is not defined clutch signal is not plausible Voltage above upper limit Voltage below lower limit 来自CAN的离合器信号不可信 离合器状态信号不可信 环境温度传感器电压超出上限门槛值 环境温度传感器电压低于下限门槛值 Signal error, only in case of 来自CAN的环境温度传感器信号不可信 CAN Voltage above upper limit 环境温度传感器BET电压超出上限门槛值 Voltage below lower limit 环境温度传感器BET电压低于下限门槛值 Voltage above upper limit 电压高于上限 Voltage below lower limit 电压低于下限 Voltage above upper limit 电压高于上限 Voltage below lower limit 电压低于下限 环境温度传感器CLgZn电压超出上限门槛 值 环境温度传感器CLgZn电压低于下限门槛 值 环境温度传感器InAir电压超出上限门槛 值 环境温度传感器InAir电压低于下限门槛 值 Low Idle and Service Brake Pre-Selection switch 排气制动开关均激活并超过一段时间 inputs are Not Plausible Short Circuit to Battery/ excess temperature EGR旁通阀对电源短路或超温 Short Circuit to Ground EGR旁通阀对地短路 No Load 没有EGR旁通阀信号 Button is Stucked 按钮卡住 车下启动/停止按钮卡住 Voltage above upper limit 电压高于上限 Voltage below lower limit 电压低于下限 排气管压力传感器电压超出上限门槛值 排气管压力传感器电压低于下限门槛值 排气管压力传感器信号不可信 Short Circuit Battery EGR对电源短路故障 Short Circuit Ground EGR对地短路故障 No Load 没有EGR信号 Excess Temperature EGR超温 BackUp mode active 只有凸轮轴信号，进入跛形回家状态 no camshaft signal wrong camshaft signal no crankshaft signal wrong crankshaft signal offset between camshaft and crankshaft Overspeed detected Short Circuit to Battery/ excess temperature Short Circuit to Ground 排气制动蝶阀地短路 No Load 排气制动蝶阀没有信号 Excess Temperature 排气制动蝶阀超温 Not plausible fault 油量扭矩转化不可信 Voltage above upper limit Voltage below lower limit Short Circuit to Battery 风扇执行器（PWM波）对电源短路 Short Circuit to Ground 风扇执行器（PWM波）对地短路 没有凸轮轴信号 凸轮轴信号不可靠 没有曲轴信号 曲轴信号不可信 曲轴与凸轮轴信号偏差超出门槛值 发动机转速超限 排气制动蝶阀对电源短路或者超温 燃油温度传感器电压超出上限门槛值 燃油温度传感器电压超出下限门槛值 No Load 风扇执行器（PWM波）没有信号 Excess Temperature 风扇执行器（PWM波）超温 Short Circuit to Battery Short Circuit to Ground Short Circuit to Battery Short Circuit to Ground Voltage above upper limit Voltage below lower limit 风扇执行器（数字信号）对电源短路 风扇执行器（数字信号）对地短路 冷却风扇速度高出上限门槛值 冷却风扇速度低于下限门槛值 燃油滤清器压差传感器电压高出上限门 槛值 燃油滤清器压差传感器电压低于下限门 槛值 Fuel filter fouling switch not 燃油滤清器压差传感器信号不可信 plausible Short Circuit Battery 燃油滤清器加热器对电源短路 Short Circuit Ground Voltage above upper limit Voltage below lower limit Fuel filter fouled set when sensor is active Sensor Short Circuit to Battery Sensor Short Circuit to Ground Sensor Open Defective Intelligent Device Sensor Short Circuit to Battery Sensor Short Circuit to Ground Sensor Open CAN -RxEngTmp2Sens 通讯错误 Defective Intelligent Device CAN -RxEngTmp2Sens 通讯错误 timeout for DashDspl Timeout of CAN message EBC1 timeout for ERC1DR CAN -TODashDspl 通讯错误 CAN-TOEBC1 通讯错误 CAN-TOERC1DR 通讯错误 燃油滤清器加热器对地短路 油中有水传感器电压超出上限门槛值 油中有水传感器电压低于下限门槛值 燃油滤清器堵塞 油中有水传感器检测到油中有水 CAN-EngGsFlRtHtr 通讯错误 CAN-EngGsFlRtHtr 通讯错误 CAN-EngGsFlRtHtr 通讯错误 CAN-EngGsFlRtHtr 通讯错误 CAN -RxEngTmp2Sens 通讯错误 CAN -RxEngTmp2Sens 通讯错误 Timeout of CAN message ETC1 timeout for EngGsFlowRt timeout for HRVD timeout for RxAMCON Fadeout is inactive and time-out of message timeout for RxEngTemp2 Timeout of CAN message TCO1 timeout for TF timeout for TSC1-AE, when active timeout for TSC1-AE, when inactive timeout for TSC1-AR, when active timeout for TSC1-AR, when inactive timeout for TSC1-DE, when active timeout for TSC1-DE, when inactive timeout for TSC1-DR, when active timeout for TSC1-DR, when inactive timeout for TSC1-PE, when active timeout for TSC1-PE, when inactive timeout for TSC1-TE, when active timeout for TSC1-TE, when inactive timeout for TSC1-TR, when active timeout for TSC1-TR, when inactive timeout for TSC1-VE, when active timeout for TSC1-VE, when inactive timeout for TSC1-VR, when active timeout for TSC1-VR, when inactive timeout for TimeDate Timeout of CAN message WSI CAN -TOETC1 通讯错误 CAN -TOEngGsFlowR 通讯错误 CAN -TOHRVD 通讯错误 CAN -TORxAMCON 通讯错误 CAN-TORxCCVS 通讯错误 CAN-TORxEngTemp2 通讯错误 CAN-TOTCO1 通讯错误 CAN-TOTF 通讯错误 CAN -OTSC1AE 通讯错误 CAN -OTSC1AE 通讯错误 CAN -TOTSC1AR 通讯错误 CAN -TOTSC1AR 通讯错误 CAN-TOTSC1DE 通讯错误 CAN-TOTSC1DE 通讯错误 CAN -TOTSC1DR 通讯错误 CAN -TOTSC1DR 通讯错误 CAN-TOTSC1PE 通讯错误 CAN-TOTSC1PE 通讯错误 CAN-TOTSC1TE 通讯错误 CAN-TOTSC1TE 通讯错误 CAN -TOTSC1TR 通讯错误 CAN -TOTSC1TR 通讯错误 CAN-TOTSC1VE 通讯错误 CAN-TOTSC1VE 通讯错误 CAN-TOTSC1VR 通讯错误 CAN-TOTSC1VR 通讯错误 CAN -TOTimeDate 通讯错误 CAN -TOWSI 通讯错误 Timeout in CAN send messages physical unplausibility of TSC-demand Short Circuit Battery Short Circuit Ground No Load Excess Temperature Short Circuit Battery Short Circuit Ground No Load Excess Temperature Short Circuit Battery Short Circuit Ground No Load Excess Temperature communication error of CJ940 error during last read operation error during last write operation default value used CAN -TxTO通讯错误 档位提升间隙时间过长 指示灯1电源短路 指示灯1地短路 指示灯1没有信号 指示灯1超温 指示灯2电源短路 指示灯2地短路 指示灯2没有信号 指示灯2超温 指示灯3电源短路 指示灯3地短路 指示灯3没有信号 指示灯3超温 CJ940通讯受干扰 EEPROM报警 EEPROM读错误 EEPROM写错误 EEPROM使用替代值 a recovery has occurred a recovery has occurred a recovery has occurred internal supply voltage upper limit internal supply voltage lower limit Ratio value above upper limit Ratio value below lower Limit Voltage above upper limit 系统修复故障 系统修复故障 系统修复故障 CJ940电压过高 CJ940电压过低 空气湿度传感器电压超出上限门槛值 空气湿度传感器电压低于下限门槛值 进气温度传感器电压超出上限门槛值 Voltage below lower Limit CAN signal defect Number of injections limited by charge balance Number of injections limited by quantity balance Number of injections limited by software short circuit 进气温度传感器电压低于下限门槛值 来自CAN进气温度传感器电压信号不可信 理想喷油次数受电流限制 理想喷油次数受油量限制 理想喷油次数受软件限制 1、2、3缸中某喷油器高端与电源或地短 路 short circuit on Low Side to ground 1、2、3缸中某喷油器低端与地短路 depending on application 看实际应用情况 not-classifyable error 没有标定的错误 depending on application 看实际应用情况 depending on application 看实际应用情况 open load 1、2、3缸中某喷油器断路 depending on application 看实际应用情况 short circuit 4、5、6缸中某喷油器高端与电源或地短 路 short circuit on Low Side to ground 4、5、6缸中某喷油器低端与地短路 depending on application 看实际应用情况 not-classifyable error 没有标定的错误 depending on application 看实际应用情况 depending on application 看实际应用情况 open load 4、5、6缸中某喷油器断路 depending on application 看实际应用情况 CY33X internal reset / clockloss / undervoltage CY33X is unlocked / CY33X init error CY33X is in Testmode CY33X 内部重新起动/时钟丢失/电压太 高 CY33X 没有被锁定/初始化错误 CY33X工作在测试模式下 CY33X SPI communication CY33X SPI 通讯错误 error /checksum/readback CY33X internal parity error CY33X内部奇偶错误 CY33X internal program flow error CY33X check of inv. YSEL during ON failed CY33X ON timeout for at least 1 cylinder short circuit on Low Side to battery depending on application 看实际应用情况 short circuit Low Side to High Side not-classifyable error 没有标定的错误 depending on application depending on application open load depending on application 看实际应用情况 看实际应用情况 喷油器1开路 看实际应用情况 CY33X 程序错误 CY33X初始化错误 某缸的CY33X 不工作 喷油器1低端与电源短路 喷油器1高端与低端短路 short circuit on Low Side to battery 喷油器2低端与电源短路 depending on application 看实际应用情况 short circuit Low Side to High Side not-classifyable error 没有标定的错误 depending on application depending on application 看实际应用情况 看实际应用情况 喷油器2高端与低端短路 open load depending on application 喷油器2开路 看实际应用情况 short circuit on Low Side to battery 喷油器3低端与电源短路 depending on application 看实际应用情况 short circuit Low Side to High Side not-classifyable error 没有标定的错误 depending on application depending on application open load depending on application 看实际应用情况 看实际应用情况 喷油器3开路 看实际应用情况 喷油器3高端与低端短路 short circuit on Low Side to battery 喷油器4低端与电源短路 depending on application 看实际应用情况 short circuit Low Side to High Side not-classifyable error 没有标定的错误 depending on application depending on application open load depending on application 看实际应用情况 看实际应用情况 喷油器4开路 看实际应用情况 喷油器4高端与低端短路 short circuit on Low Side to battery 喷油器5低端与电源短路 depending on application 看实际应用情况 short circuit Low Side to High Side 喷油器5高端与低端短路 not-classifyable error 没有标定的错误 depending on application depending on application open load depending on application 看实际应用情况 看实际应用情况 喷油器5开路 看实际应用情况 short circuit on Low Side to battery 喷油器6低端与电源短路 depending on application 看实际应用情况 short circuit Low Side to High Side not-classifyable error 没有标定的错误 depending on application depending on application open load depending on application The minimal number of injections was not reached 看实际应用情况 看实际应用情况 喷油器6开路 看实际应用情况 正常工作的气缸数小于系统运转所需的 最小缸数 喷油器6高端与低端短路 not used 未用 not used 未用 not used 未用 invalid switch combinations 巡航信号不可靠 Short Circuit Battery Short Circuit Ground 故障灯与电源短路 故障灯与地短路 No Load Excess Temperature SCB error SCG error Short circuit to battery Short circuit to ground 故障灯没有信号 故障灯超温 主继电器2对电源短路 主继电器2对地短路 巡航开关对电源短路 巡航开关对地短路 Multiple state switch not 巡航开关信号不可信 plausible Short circuit to battery error 主继电器1电源短路 Short circuit to ground error Set, if error-counter of Watchdog or controller are not plausible or the system must shut down 系统通讯故障 主继电器1地短路 Busoff in CAN A Busoff in CAN B Busoff in CAN C Voltage above upper limit Voltage below lower limit signal from CAN not OK plausibility error Voltage above upper limit Voltage below lower limit Hardware signal error Plausibility check - oil pressure too high Plausibility check - oil pressure too low Voltage above upper limit Voltage below lower limit signal error for CAN CANA 通讯关闭 CANB 通讯关闭 CAN C通讯关闭 机油液位传感器电压电压超出上限 机油液位传感器电压电压低于下限 来自CAN的机油液位传感器信号不可靠 机油液位传感器信号不可靠 机油压力传感器电压电压超出上限 机油压力传感器电压电压低于下限 机油压力传感器信号不可靠 机油压力过高或机油温度信号不可靠 机油压力过低 机油温度传感器电压超出上限门槛值 机油温度传感器电压低于下限门槛值 来自CAN的机油温度传感器信号不可信 Plausibility error between OTS and CTS Plausibility error OTS temperature above normal Energising time exceeds limit of overrun monitoring Plausibility error in engine speed check 机油温度与冷却水温度信号 机油温度与冷却水温度信号 喷油器加电时间超出超速监视器设定值 发动机转速不可信 positive governor deviation 压力调节正偏差超出上限 above limit negative governor 压力调节负偏差低于下限 deviation below limit Short Circuit Battery 电动燃油泵对电源短路 Short Circuit Ground No Load Excess Temperature is set to deaktivate misfire detection during runup test Watch dog switch off path defect Voltage monitoring upper limit shut off path defect Voltage monitoring lower limit shut off path defect Voltage above upper limit 传感器电源1电压超出上限门槛值 Voltage below lower limit 传感器电源1电压超出下限门槛值 Voltage above upper limit 传感器电源2电压超出上限门槛值 Voltage below lower limit 传感器电源2电压超出下限门槛值 Voltage above upper limit 传感器电源3电压超出上限门槛值 Voltage below lower limit 传感器电源3电压超出下限门槛值 断缸测试故障 Short Circuit Battery Short Circuit Ground 系统灯电源短路 系统灯地短路 电动燃油泵对地短路 电动燃油泵断路 电动燃油泵超温 加速测试错误 看门狗开关错误 冗余断缸测试电压超出上限 冗余断缸测试电压低于下限 No Load Excess Temperature No Terminal 15 signals detected Terminal 50 always pressed Deviation between TPU and system time Short Circuit Battery 没有系统灯信号 系统灯超温 T15信号错误 T50接通时间超限 时间处理器与系统计时器间的时间偏差 超出门槛值 空气节流阀对电源短路 Short Circuit Ground 空气节流阀对地短路 No Load 空气节流阀没有信号 Excess Temperature 空气节流阀超温 exceeding of the maximum 车速1高于最大门槛值 vehicle speed distance factor not learned VSS或SPS传感器信号失效 HW signal for vehicle speed not valid vehicle speed not plausible with injection mass and engine speed Voltage Monitoring SRC Maximum Voltage Monitoring SRC Minimum CAN signal for vehicle speed not valid Voltage Monitoring SRC not plausible exceeding of the maximum pulse width exceeding of the minimum pulse width HW signal frequency is not valid Signal fault 车速1的HW信号不可信 车速1与喷油量及发动机转速不可信 车速2传感器电压高出上限门槛值 车速2传感器电压低于下限门槛值 来自CAN的车速信号无效 车速2传感器电压信号不可信 车速3信号脉宽超过上限门槛值 车速3信号脉宽低于下限门槛值 车速信号平均周期小于门槛值 CAN 通讯节点错误 Not plausible fault CAN 通讯节点错误 Set, if SPI-communication failed Short Circuit Battery Short Circuit Ground No Load Excess Temperature Short Circuit Battery Short Circuit Ground No Load Excess Temperature signal range check high error of BPA AD-channel signal range check low error of BPA AD-channel signal error of current through BPA HpTst deactivates rail pressure monitoring open load of metering unit output excess temperature of metering unit powerstage short circuit to battery of metering unit output short circuit to ground of metering unit output signal range check high error of metering unit ADchannel signal range check low error of metering unit ADchannel PRV was recognised as OPEN pressure shock requested SPI通讯错误 故障指示灯电源短路 故障指示灯对地短路 没有故障指示灯信号 故障指示灯超温 空调压缩机对电源短路 空调压缩机对地短路 空调压缩机没有信号 空调压缩机超温 BPA的AD转换信号超出上限 BPA的AD转换信号低于下限 BPA信号错误 高压测试错误 燃油计量器开路 燃油计量器超温 燃油计量器电源短路 燃油计量器对地短路 燃油计量器电压超过上限 燃油计量器电压低于下限 共轨泻压阀打开 轨压要求时间超限 PRV did not open after pressure shock Voltage above upper limit Voltage below lower limit RPS raw value is above maximum offset RPS raw value is below minimum offset maximum positive deviation of rail pressure exceeded maximum positive deviation of rail pressure exceeded concerning set flow of fuel maximum negative rail pressure deviation with metering unit on lower limit is exceeded minimum rail pressure exceeded maximum rail pressure exceeded rail pressure drop rate is higher then expected setpoint of metering unit in overrun mode not plausible setpoint of fuel volume flow throught the metering unit is lower then the calculated limit value maximum positive deviation of governor exceeded concerning set flow of fuel Voltage above upper limit Voltage below lower limit Short Circuit Battery 压力波动时共轨泻压阀没有打开 轨压传感器电压超出上限门槛值 轨压传感器电压低于下限门槛值 轨压传感器电压超出最大偏差 轨压传感器电压低于最小偏差 轨压偏差超出上限门槛值 轨压偏差超出上限门槛值并且喷油量超 限 轨压偏差低于下限门槛值并且喷油量低 于门槛值 轨压峰值低于下限门槛值 轨压峰值超出上限门槛值 轨压下降过快 超速模式下的油量剂量单元设定不可信 燃油计量器中的油量超过门槛值 轨压偏差超出门槛值并且燃油计量器中 的油量超过门槛值 12V传感器电源电压超过上限门槛值 12V传感器电源低于下限门槛值 起动电机高端电源短路 Short Circuit Ground 起动电机高端对地短路 Short Circuit Battery 起动电机低端电源短路 Short Circuit Ground 起动电机低端对地短路 No Load 起动电机开路 Coolant temperature above 冷却水温过热故障 threshold 水温传感器工作正常但水温超出门槛值 空转时，识别油量计量单元的变量修正 错误 制动开关错误的识别错误 制动踏板踩下前，巡航控制抑制错误 巡航控制要求的识别错误，使得故障灯 常亮 远程油门踏板1输出电压值超出上限 远程油门踏板1输出电压值低于下限 远程油门踏板1与远程油门踏板2的2倍的 信号关系不可信 远程油门踏板2输出电压值超出上限 远程油门踏板2输出电压值低于下限 远程油门踏板2与远程油门踏板1的1/2的 信号关系不可信 油门踏板传感器#1信号过低 油门踏板传感器#1信号过高 油门踏板传感器#2信号过低 油门踏板传感器#2信号过高 油门踏板传感器#1常开 油门踏板传感器#2常开 油门踏板传感器#1常闭 油门踏板传感器#2常闭 油门踏板传感器#1和#2信号无效 怠速开关粘黏常开 怠速开关粘黏常闭 进气压力传感器信号过高 进气压力传感器信号过低 进气压力传感器无效 PTO踏板传感器信号过低 PTO踏板传感器信号过高 共轨压力传感器信号过高 共轨压力传感器信号过低 共轨压力传感器信号恒值 蓄电池电压过高 蓄电池电压过低 水温传感器信号过高 水温传感器信号过低 燃油温度传感器信号过高 燃油温度传感器信号过低 进气温度传感器信号过高 进气温度传感器信号过低 大气压力传感器信号过高 大气压力传感器信号过低 怠速量大小信号过高 怠速量大小信号过低 起动机开关对电源短路 曲轴转角传感器无脉冲信号 凸轮转角传感器无脉冲信号 凸轮转角和曲轴转角传感器无脉冲信号 车速传感器信号频率过高 车速传感器信号频率短路或开路 车速传感器信号无效 排气制动阀输出开路或对地短路 排气制动阀输出对电源短路 喷油器公共端COM1对电源短路 喷油器公共端COM1对地短路 喷油器公共端COM1开路 喷油器公共端COM2对电源短路 喷油器公共端COM2对地短路 喷油器公共端COM2开路 喷油器#1电磁线圈开路 喷油器#2电磁线圈开路 喷油器#3电磁线圈开路 喷油器#4电磁线圈开路 喷油器#5电磁线圈开路 喷油器#6电磁线圈开路 电容充电电路由于充电不足导致失效 电容充电电路由于充电过度导致失效 SCV( )/SCV(-)输出对电源短路 SCV( )/SCV(-)输出开路或对地短路/SCV线圈开路 供油泵控制阀（吸油控制阀）粘黏 共轨压力传感器性能失效（包括漏油） 供油泵保护 供油泵更换 供油泵失效（流量不足） 压力限制器打开 共轨压力超过上限 共轨压力超过最高限制 气缸#1供油系统故障 气缸#2供油系统故障 气缸#3供油系统故障 气缸#4供油系统故障 气缸#5供油系统故障 气缸#6供油系统故障 发动机转速超速 预热继电器对地短路 预热继电器开路或对电源短路 发动机停车开关粘黏常开 冷却水温超过上限 进气压力超过上限 进气压力低于下限 倒档开关开路或对地短路 倒档开关对电源短路 CAN#1节点出错 CAN#2节点出错 离合器开关电路失效 空挡开关电路失效 F/D#1回路被激活 F/D#2回路被激活 F/D#3回路被激活 F/D#4回路被激活 F/D#5回路被激活 F/D#6回路被激活 与AT连接的CAN总线开路 与ABS连接的CAN总线开路 与仪表连接的CAN总线开路 主继电器粘黏常闭 巡航开关电路失效 QR码没有写入 QR码错误 QR码定义错误 CPU出错 主CPU出错 FLASH校验和错误 机油压力传感器信号过高 机油压力传感器信号过低 机油压力过低 冷却液位过低 缸内制动#1电磁阀输出开路或对地短路 缸内制动#1电磁阀输出对电源短路 缸内制动#2电磁阀输出开路或对地短路 缸内制动#2电磁阀输出对电源短路 SCV线圈短路 油水分离器中液位过高 |
|
|
来自： 昵称58482583 > 《待分类》
